Name:
Zirconyl(IV) chloride octahydrate 98+%
Synonym:
Zirconium(IV)oxide chloride octahydrate; Dichlorooxozirconium octahydrate; Zirconium chloride oxide octahydrate; Zirconium dichloride monoxide octahydrate; Zirconium monoxide dichloride octahydrate; Zirconium oxychloride octahydrate
CAS:
7699-43-6
Section 1 - Chemical Product
MSDS Name:Zirconyl(IV) chloride octahydrate 98+%
Synonym:Zirconium(IV)oxide chloride octahydrate; Dichlorooxozirconium octahydrate; Zirconium chloride oxide octahydrate; Zirconium dichloride monoxide octahydrate; Zirconium monoxide dichloride octahydrate; Zirconium oxychloride octahydrate
Synonym:Zirconium(IV)oxide chloride octahydrate; Dichlorooxozirconium octahydrate; Zirconium chloride oxide octahydrate; Zirconium dichloride monoxide octahydrate; Zirconium monoxide dichloride octahydrate; Zirconium oxychloride octahydrate
Section 2 - COMPOSITION, INFORMATION ON INGREDIENTS
| CAS# | Chemical Name | emsds | EINECS# |
| 7699-43-6 | Zirconyl(IV)chloride octahydrate | >98 | unlisted |
| Hazard Symbols: C Risk Phrases: 22 34 |
Section 3 - HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
Harmful if swallowed. Causes burns.Hygroscopic (absorbs moisture from the air).
Potential Health Effects
Eye:
Causes eye burns.
Skin:
Causes skin burns.
Ingestion:
May cause severe and permanent damage to the digestive tract. Causes gastrointestinal tract burns.
Inhalation:
May cause irritation of the respiratory tract with burning pain in the nose and throat, coughing, wheezing, shortness of breath and pulmonary edema. Causes chemical burns to the respiratory tract.
Inhalation may be fatal as a result of spasm, inflammation, edema of the larynx and bronchi, chemical pneumonitis and pulmonary edema.
Chronic:
Not available.
Harmful if swallowed. Causes burns.Hygroscopic (absorbs moisture from the air).
Potential Health Effects
Eye:
Causes eye burns.
Skin:
Causes skin burns.
Ingestion:
May cause severe and permanent damage to the digestive tract. Causes gastrointestinal tract burns.
Inhalation:
May cause irritation of the respiratory tract with burning pain in the nose and throat, coughing, wheezing, shortness of breath and pulmonary edema. Causes chemical burns to the respiratory tract.
Inhalation may be fatal as a result of spasm, inflammation, edema of the larynx and bronchi, chemical pneumonitis and pulmonary edema.
Chronic:
Not available.
Section 4 - FIRST AID MEASURES
Eyes: In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. Get medical aid immediately.
Skin:
In case of contact, immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Get medical aid immediately. Wash clothing before reuse.
Ingestion:
If swallowed, do NOT induce vomiting. Get medical aid immediately.
If victim is fully conscious, give a cupful of water. Never give anything by mouth to an unconscious person.
Inhalation:
If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical aid.
Notes to Physician:
Treat symptomatically and supportively.
Skin:
In case of contact, immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Get medical aid immediately. Wash clothing before reuse.
Ingestion:
If swallowed, do NOT induce vomiting. Get medical aid immediately.
If victim is fully conscious, give a cupful of water. Never give anything by mouth to an unconscious person.
Inhalation:
If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical aid.
Notes to Physician:
Treat symptomatically and supportively.
Section 5 - FIRE FIGHTING MEASURES
General Information:
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. During a fire, irritating and highly toxic gases may be generated by thermal decomposition or combustion.
Extinguishing Media:
Use extinguishing media most appropriate for the surrounding fire.
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. During a fire, irritating and highly toxic gases may be generated by thermal decomposition or combustion.
Extinguishing Media:
Use extinguishing media most appropriate for the surrounding fire.
Section 6 - ACCIDENTAL RELEASE MEASURES
General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks:
Vacuum or sweep up material and place into a suitable disposal container. Clean up spills immediately, observing precautions in the Protective Equipment section. Avoid generating dusty conditions.
Provide ventilation.
Spills/Leaks:
Vacuum or sweep up material and place into a suitable disposal container. Clean up spills immediately, observing precautions in the Protective Equipment section. Avoid generating dusty conditions.
Provide ventilation.
Section 7 - HANDLING and STORAGE
Handling:
Do not breathe dust, vapor, mist, or gas. Do not get in eyes, on skin, or on clothing. Keep container tightly closed. Do not get on skin or in eyes. Do not ingest or inhale. Use with adequate ventilation. Use only in a chemical fume hood. Discard contaminated shoes.
Storage:
Store in a cool, dry place. Keep container closed when not in use.
Store in a tightly closed container. Corrosives area.
Do not breathe dust, vapor, mist, or gas. Do not get in eyes, on skin, or on clothing. Keep container tightly closed. Do not get on skin or in eyes. Do not ingest or inhale. Use with adequate ventilation. Use only in a chemical fume hood. Discard contaminated shoes.
Storage:
Store in a cool, dry place. Keep container closed when not in use.
Store in a tightly closed container. Corrosives area.
Section 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION
Engineering Controls:
Use process enclosure, local exhaust ventilation, or other engineering controls to control airborne levels below recommended exposure limits. Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower.
Exposure Limits CAS# 7699-43-6: United Kingdom, WEL - TWA: (listed as zirconium compounds, n.o.s.
mg/m3 TWA (as Zr) United Kingdom, WEL - STEL: (listed as zirconium compounds, n.o.s 10 mg/m3 STEL (as Zr) United States OSHA: 5 mg/m3 TWA (as Zr) (listed under Zirconium compounds, n.o.s.).
Belgium - TWA: (listed as zirconium compounds, n.o.s.): 5 mg/m3 V (as Zr) Belgium - STEL: (listed as zirconium compounds, n.o.s.): 10 mg/m3 (as Zr) Malaysia: (listed as zirconium compounds, n.o.s.): 5 mg/m3 TWA (a Zr) Netherlands: (listed as zirconium compounds, n.o.s.): 5 mg/m3 MAC Zr) Spain: (listed as zirconium compounds, n.o.s.): 5 mg/m3 VLA-ED (a Zr) Spain: (listed as zirconium compounds, n.o.s.): 10 mg/m3 VLA-EC ( Zr) CAS# 13520-92-8: United Kingdom, WEL - TWA: (listed as zirconium compounds, n.o.s.
mg/m3 TWA (as Zr) United Kingdom, WEL - STEL: (listed as zirconium compounds, n.o.s 10 mg/m3 STEL (as Zr) United States OSHA: 5 mg/m3 TWA (as Zr) (listed under Zirconium compounds, n.o.s.).
Belgium - TWA: (listed as zirconium compounds, n.o.s.): 5 mg/m3 V (as Zr) Belgium - STEL: (listed as zirconium compounds, n.o.s.): 10 mg/m3 (as Zr) Malaysia: (listed as zirconium compounds, n.o.s.): 5 mg/m3 TWA (a Zr) Netherlands: (listed as zirconium compounds, n.o.s.): 5 mg/m3 MAC Zr) Spain: (listed as zirconium compounds, n.o.s.): 5 mg/m3 VLA-ED (a Zr) Spain: (listed as zirconium compounds, n.o.s.): 10 mg/m3 VLA-EC ( Zr) Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHAs eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
A respiratory protection program that meets OSHAs 29 CFR 1910.134 and ANSI Z88.2 requirements or European Standard EN 149 must be followed whenever workplace conditions warrant respirator use. Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced.
Use process enclosure, local exhaust ventilation, or other engineering controls to control airborne levels below recommended exposure limits. Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower.
Exposure Limits CAS# 7699-43-6: United Kingdom, WEL - TWA: (listed as zirconium compounds, n.o.s.
mg/m3 TWA (as Zr) United Kingdom, WEL - STEL: (listed as zirconium compounds, n.o.s 10 mg/m3 STEL (as Zr) United States OSHA: 5 mg/m3 TWA (as Zr) (listed under Zirconium compounds, n.o.s.).
Belgium - TWA: (listed as zirconium compounds, n.o.s.): 5 mg/m3 V (as Zr) Belgium - STEL: (listed as zirconium compounds, n.o.s.): 10 mg/m3 (as Zr) Malaysia: (listed as zirconium compounds, n.o.s.): 5 mg/m3 TWA (a Zr) Netherlands: (listed as zirconium compounds, n.o.s.): 5 mg/m3 MAC Zr) Spain: (listed as zirconium compounds, n.o.s.): 5 mg/m3 VLA-ED (a Zr) Spain: (listed as zirconium compounds, n.o.s.): 10 mg/m3 VLA-EC ( Zr) CAS# 13520-92-8: United Kingdom, WEL - TWA: (listed as zirconium compounds, n.o.s.
mg/m3 TWA (as Zr) United Kingdom, WEL - STEL: (listed as zirconium compounds, n.o.s 10 mg/m3 STEL (as Zr) United States OSHA: 5 mg/m3 TWA (as Zr) (listed under Zirconium compounds, n.o.s.).
Belgium - TWA: (listed as zirconium compounds, n.o.s.): 5 mg/m3 V (as Zr) Belgium - STEL: (listed as zirconium compounds, n.o.s.): 10 mg/m3 (as Zr) Malaysia: (listed as zirconium compounds, n.o.s.): 5 mg/m3 TWA (a Zr) Netherlands: (listed as zirconium compounds, n.o.s.): 5 mg/m3 MAC Zr) Spain: (listed as zirconium compounds, n.o.s.): 5 mg/m3 VLA-ED (a Zr) Spain: (listed as zirconium compounds, n.o.s.): 10 mg/m3 VLA-EC ( Zr) Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHAs eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
A respiratory protection program that meets OSHAs 29 CFR 1910.134 and ANSI Z88.2 requirements or European Standard EN 149 must be followed whenever workplace conditions warrant respirator use. Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced.
Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Solid
Color: off-white
Odor: None reported.
pH: < 1 (33% soln)
Vapor Pressure: Not available.
Viscosity: Not available.
Boiling Point: Not available.
Freezing/Melting Point: Not available.
Autoignition Temperature: Not available.
Flash Point: Not applicable.
Explosion Limits, lower: N/A
Explosion Limits, upper: N/A
Decomposition Temperature: >150 deg C
Solubility in water: Freely Soluble.
Specific Gravity/Density: 1.9100 g/cm3
Molecular Formula: Cl2OZr.8H2O
Molecular Weight: 322.25
Section 10 - STABILITY AND REACTIVITY
Chemical Stability:
Stable under normal temperatures and pressures.
Conditions to Avoid:
Excess heat.
Incompatibilities with Other Materials:
Strong oxidizing agents, strong acids, strong bases.
Hazardous Decomposition Products:
Hydrogen chloride, chlorine, irritating and toxic fumes and gases, chloride fumes.
Hazardous Polymerization: Has not been reported.
Stable under normal temperatures and pressures.
Conditions to Avoid:
Excess heat.
Incompatibilities with Other Materials:
Strong oxidizing agents, strong acids, strong bases.
Hazardous Decomposition Products:
Hydrogen chloride, chlorine, irritating and toxic fumes and gases, chloride fumes.
Hazardous Polymerization: Has not been reported.
Section 11 - TOXICOLOGICAL INFORMATION
RTECS#:
CAS# 7699-43-6: ZH7700000 CAS# 13520-92-8: ZH7250000 LD50/LC50:
CAS# 7699-43-6: Oral, mouse: LD50 = 1227 mg/kg; Oral, rat: LD50 = 2950 mg/kg.
CAS# 13520-92-8: Oral, rat: LD50 = 990 mg/kg.
Carcinogenicity:
Zirconium oxychloride anhydrous - Not listed by ACGIH, IARC, or NTP.
Zirconyl(IV)chloride octahydrate - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
CAS# 7699-43-6: ZH7700000 CAS# 13520-92-8: ZH7250000 LD50/LC50:
CAS# 7699-43-6: Oral, mouse: LD50 = 1227 mg/kg; Oral, rat: LD50 = 2950 mg/kg.
CAS# 13520-92-8: Oral, rat: LD50 = 990 mg/kg.
Carcinogenicity:
Zirconium oxychloride anhydrous - Not listed by ACGIH, IARC, or NTP.
Zirconyl(IV)chloride octahydrate - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
Section 12 - ECOLOGICAL INFORMATION
Section 13 - DISPOSAL CONSIDERATIONS
Dispose of in a manner consistent with federal, state, and local regulations.
Section 14 - TRANSPORT INFORMATION
IATA
Shipping Name: CORROSIVE SOLID, N.O.S.*
Hazard Class: 8
UN Number: 1759
Packing Group: III
IMO
Shipping Name: CORROSIVE SOLID, N.O.S.
Hazard Class: 8
UN Number: 1759
Packing Group: III
RID/ADR
Shipping Name: CORROSIVE SOLID, N.O.S.
Hazard Class: 8
UN Number: 1759
Packing group: III
Section 15 - REGULATORY INFORMATION
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: C
Risk Phrases:
R 22 Harmful if swallowed.
R 34 Causes burns.
Safety Phrases:
S 26 In case of contact with eyes, rinse immediately
with plenty of water and seek medical advice.
S 36/37/39 Wear suitable protective clothing, gloves
and eye/face protection.
S 45 In case of accident or if you feel unwell, seek
medical advice immediately (show the label where
possible).
WGK (Water Danger/Protection)
CAS# 7699-43-6: No information available.
CAS# 13520-92-8: No information available.
Canada
CAS# 7699-43-6 is listed on Canadas DSL List.
CAS# 7699-43-6 is not listed on Canadas Ingredient Disclosure List.
CAS# 13520-92-8 is not listed on Canadas Ingredient Disclosure List.
US FEDERAL
TSCA
CAS# 7699-43-6 is listed on the TSCA inventory.
CAS# 13520-92-8 is not on the TSCA Inventory because it is a hydrate.
It is considered to be listed if the CAS number for the anhydrous form
is on the inventory (40CFR720.3(u)(2)).
