Name:
Ammonia solution in methanol ca. 7N
Synonym:
None
CAS:
67-56-1
Section 1 - Chemical Product
MSDS Name:Ammonia solution in methanol ca. 7N
Synonym:None
Synonym:None
Section 2 - COMPOSITION, INFORMATION ON INGREDIENTS
| CAS# | Chemical Name | emsds | EINECS# |
| 67-56-1 | Methyl alcohol | 88.1 | 200-659-6 |
| Hazard Symbols: T F C Risk Phrases: 11 23/24/25 34 39/23/24/25 |
Section 3 - HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
Highly flammable. Toxic by inhalation, in contact with skin and if swallowed. Causes burns. Toxic : danger of very serious irreversible effects through inhalation, in contact with skin and if swallowed.Hygroscopic (absorbs moisture from the air).
Potential Health Effects
Eye:
Methanol is a mild to moderate eye irritant. Inhalation, ingestion or skin absorption of methanol can cause significant disturbances in vision, including blindness.
Skin:
Causes moderate skin irritation. Harmful if absorbed through the skin. Prolonged and/or repeated contact may cause defatting of the skin and dermatitis. Methanol can be absorbed through the skin, producing systemic effects that include visual disturbances.
Ingestion:
Harmful if swallowed. May be fatal or cause blindness if swallowed.
Aspiration hazard. May cause systemic toxicity with acidosis. May cause central nervous system depression, characterized by excitement, followed by headache, dizziness, drowsiness, and nausea.
Advanced stages may cause collapse, unconsciousness, coma and possible death due to respiratory failure.
Inhalation:
Methanol is toxic and can very readily form extremely high vapor concentrations at room temperature. Inhalation is the most common route of occupational exposure. At first, methanol causes CNS depression with nausea, headache, vomiting, dizziness and incoordination. A time period with no obvious symptoms follows (typically 8-24 hrs). This latent period is followed by metabolic acidosis and severe visual effects which may include reduced reactivity and/or increased sensitivity to light, blurred, double and/or snowy vision, and blindness. Depending on the severity of exposure and the promptness of treatment, survivors may recover completely or may have permanent blindness, vision disturbances and/or nervous system effects.
Chronic:
Prolonged or repeated skin contact may cause dermatitis. Chronic exposure may cause effects similar to those of acute exposure.
Methanol is only very slowly eliminated from the body. Because of this slow elimination, methanol should be regarded as a cumulative poison. Though a single exposure may cause no effect, daily exposures may result in the accumulation of a harmful amount. Methanol has produced fetotoxicity in rats and teratogenicity in mice exposed by inhalation to high concentrations that did not produce significant maternal toxicity.
Highly flammable. Toxic by inhalation, in contact with skin and if swallowed. Causes burns. Toxic : danger of very serious irreversible effects through inhalation, in contact with skin and if swallowed.Hygroscopic (absorbs moisture from the air).
Potential Health Effects
Eye:
Methanol is a mild to moderate eye irritant. Inhalation, ingestion or skin absorption of methanol can cause significant disturbances in vision, including blindness.
Skin:
Causes moderate skin irritation. Harmful if absorbed through the skin. Prolonged and/or repeated contact may cause defatting of the skin and dermatitis. Methanol can be absorbed through the skin, producing systemic effects that include visual disturbances.
Ingestion:
Harmful if swallowed. May be fatal or cause blindness if swallowed.
Aspiration hazard. May cause systemic toxicity with acidosis. May cause central nervous system depression, characterized by excitement, followed by headache, dizziness, drowsiness, and nausea.
Advanced stages may cause collapse, unconsciousness, coma and possible death due to respiratory failure.
Inhalation:
Methanol is toxic and can very readily form extremely high vapor concentrations at room temperature. Inhalation is the most common route of occupational exposure. At first, methanol causes CNS depression with nausea, headache, vomiting, dizziness and incoordination. A time period with no obvious symptoms follows (typically 8-24 hrs). This latent period is followed by metabolic acidosis and severe visual effects which may include reduced reactivity and/or increased sensitivity to light, blurred, double and/or snowy vision, and blindness. Depending on the severity of exposure and the promptness of treatment, survivors may recover completely or may have permanent blindness, vision disturbances and/or nervous system effects.
Chronic:
Prolonged or repeated skin contact may cause dermatitis. Chronic exposure may cause effects similar to those of acute exposure.
Methanol is only very slowly eliminated from the body. Because of this slow elimination, methanol should be regarded as a cumulative poison. Though a single exposure may cause no effect, daily exposures may result in the accumulation of a harmful amount. Methanol has produced fetotoxicity in rats and teratogenicity in mice exposed by inhalation to high concentrations that did not produce significant maternal toxicity.
Section 4 - FIRST AID MEASURES
Eyes: In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. Get medical aid immediately.
Skin:
In case of contact, immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Get medical aid immediately. Wash clothing before reuse.
Ingestion:
Potential for aspiration if swallowed. Get medical aid immediately.
Do not induce vomiting unless directed to do so by medical personnel. Never give anything by mouth to an unconscious person.
Inhalation:
If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical aid.
Notes to Physician:
Effects may be delayed.
Antidote: Ethanol may inhibit methanol metabolism.
Skin:
In case of contact, immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Get medical aid immediately. Wash clothing before reuse.
Ingestion:
Potential for aspiration if swallowed. Get medical aid immediately.
Do not induce vomiting unless directed to do so by medical personnel. Never give anything by mouth to an unconscious person.
Inhalation:
If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical aid.
Notes to Physician:
Effects may be delayed.
Antidote: Ethanol may inhibit methanol metabolism.
Section 5 - FIRE FIGHTING MEASURES
General Information:
Containers can build up pressure if exposed to heat and/or fire. As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. During a fire, irritating and highly toxic gases may be generated by thermal decomposition or combustion. Use water spray to keep fire-exposed containers cool. Water may be ineffective.
Material is lighter than water and a fire may be spread by the use of water. Flammable liquid and vapor. Vapors are heavier than air and may travel to a source of ignition and flash back. Vapors can spread along the ground and collect in low or confined areas.
Extinguishing Media:
For small fires, use dry chemical, carbon dioxide, water spray or alcohol-resistant foam. Water may be ineffective. For large fires, use water spray, fog or alcohol-resistant foam. Do NOT use straight streams of water.
Containers can build up pressure if exposed to heat and/or fire. As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. During a fire, irritating and highly toxic gases may be generated by thermal decomposition or combustion. Use water spray to keep fire-exposed containers cool. Water may be ineffective.
Material is lighter than water and a fire may be spread by the use of water. Flammable liquid and vapor. Vapors are heavier than air and may travel to a source of ignition and flash back. Vapors can spread along the ground and collect in low or confined areas.
Extinguishing Media:
For small fires, use dry chemical, carbon dioxide, water spray or alcohol-resistant foam. Water may be ineffective. For large fires, use water spray, fog or alcohol-resistant foam. Do NOT use straight streams of water.
Section 6 - ACCIDENTAL RELEASE MEASURES
General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks:
Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in suitable container. Use water spray to disperse the gas/vapor. Remove all sources of ignition. Provide ventilation. A vapor suppressing foam may be used to reduce vapors. Water spray may reduce vapor but may not prevent ignition in closed spaces. Approach spill from upwind.
Spills/Leaks:
Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in suitable container. Use water spray to disperse the gas/vapor. Remove all sources of ignition. Provide ventilation. A vapor suppressing foam may be used to reduce vapors. Water spray may reduce vapor but may not prevent ignition in closed spaces. Approach spill from upwind.
Section 7 - HANDLING and STORAGE
Handling:
Wash thoroughly after handling. Remove contaminated clothing and wash before reuse. Ground and bond containers when transferring material. Do not get in eyes, on skin, or on clothing. Empty containers retain product residue, (liquid and/or vapor), and can be dangerous. Keep container tightly closed. Do not ingest or inhale. Do not pressurize, cut, weld, braze, solder, drill, grind, or expose empty containers to heat, sparks or open flames. Use only with adequate ventilation. Keep away from heat, sparks and flame. Avoid use in confined spaces.
Storage:
Keep away from sources of ignition. Store in a cool, dry, well-ventilated area away from incompatible substances.
Flammables-area. Keep containers tightly closed. Store protected from moisture. Refrigerate upon arrival below 4C/39F.
Wash thoroughly after handling. Remove contaminated clothing and wash before reuse. Ground and bond containers when transferring material. Do not get in eyes, on skin, or on clothing. Empty containers retain product residue, (liquid and/or vapor), and can be dangerous. Keep container tightly closed. Do not ingest or inhale. Do not pressurize, cut, weld, braze, solder, drill, grind, or expose empty containers to heat, sparks or open flames. Use only with adequate ventilation. Keep away from heat, sparks and flame. Avoid use in confined spaces.
Storage:
Keep away from sources of ignition. Store in a cool, dry, well-ventilated area away from incompatible substances.
Flammables-area. Keep containers tightly closed. Store protected from moisture. Refrigerate upon arrival below 4C/39F.
Section 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION
Engineering Controls:
Use explosion-proof ventilation equipment. Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use adequate general or local exhaust ventilation to keep airborne concentrations below the permissible exposure limits.
Exposure Limits CAS# 67-56-1: United Kingdom, WEL - TWA: 200 ppm TWA; 266 mg/m3 TWA United Kingdom, WEL - STEL: 250 ppm STEL; 333 mg/m3 STEL United States OSHA: 200 ppm TWA; 260 mg/m3 TWA Belgium - TWA: 200 ppm VLE; 266 mg/m3 VLE Belgium - STEL: 250 ppm VLE; 333 mg/m3 VLE France - VME: 200 ppm VME; 260 mg/m3 VME France - VLE: 1000 ppm VLE; 1300 mg/m3 VLE Germany: 200 ppm TWA; 270 mg/m3 TWA Germany: Skin absorber Japan: 200 ppm OEL; 260 mg/m3 OEL Malaysia: 200 ppm TWA; 262 mg/m3 TWA Netherlands: 200 ppm MAC; 260 mg/m3 MAC Russia: 5 mg/m3 TWA Spain: 200 ppm VLA-ED; 266 mg/m3 VLA-ED Spain: 250 ppm VLA-EC; 333 mg/m3 VLA-EC CAS# 7664-41-7: United Kingdom, WEL - TWA: 25 ppm TWA (anhydrous); 18 mg/m3 TWA (anhydrous) United Kingdom, WEL - STEL: 35 ppm STEL (anhydrous); 25 mg/m3 STE (anhydrous) United States OSHA: 50 ppm TWA; 35 mg/m3 TWA Belgium - TWA: 20 ppm VLE; 14 mg/m3 VLE Belgium - STEL: 50 ppm VLE; 36 mg/m3 VLE France - VME: 25 ppm VME; 18 mg/m3 VME France - VLE: 50 ppm VLE; 36 mg/m3 VLE Germany: 50 ppm TWA; 35 mg/m3 TWA Japan: 25 ppm OEL; 17 mg/m3 OEL Malaysia: 25 ppm TWA; 17 mg/m3 TWA Netherlands: 50 ppm STEL; 36 mg/m3 STEL Netherlands: 20 ppm MAC; 14 mg/m3 MAC Russia: 20 mg/m3 TWA Spain: 20 ppm VLA-ED; 14 mg/m3 VLA-ED Spain: 50 ppm VLA-EC; 36 mg/m3 VLA-EC Personal Protective Equipment Eyes: Wear chemical splash goggles.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
A respiratory protection program that meets OSHAs 29 CFR 1910.134 and ANSI Z88.2 requirements or European Standard EN 149 must be followed whenever workplace conditions warrant respirator use.
Use explosion-proof ventilation equipment. Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use adequate general or local exhaust ventilation to keep airborne concentrations below the permissible exposure limits.
Exposure Limits CAS# 67-56-1: United Kingdom, WEL - TWA: 200 ppm TWA; 266 mg/m3 TWA United Kingdom, WEL - STEL: 250 ppm STEL; 333 mg/m3 STEL United States OSHA: 200 ppm TWA; 260 mg/m3 TWA Belgium - TWA: 200 ppm VLE; 266 mg/m3 VLE Belgium - STEL: 250 ppm VLE; 333 mg/m3 VLE France - VME: 200 ppm VME; 260 mg/m3 VME France - VLE: 1000 ppm VLE; 1300 mg/m3 VLE Germany: 200 ppm TWA; 270 mg/m3 TWA Germany: Skin absorber Japan: 200 ppm OEL; 260 mg/m3 OEL Malaysia: 200 ppm TWA; 262 mg/m3 TWA Netherlands: 200 ppm MAC; 260 mg/m3 MAC Russia: 5 mg/m3 TWA Spain: 200 ppm VLA-ED; 266 mg/m3 VLA-ED Spain: 250 ppm VLA-EC; 333 mg/m3 VLA-EC CAS# 7664-41-7: United Kingdom, WEL - TWA: 25 ppm TWA (anhydrous); 18 mg/m3 TWA (anhydrous) United Kingdom, WEL - STEL: 35 ppm STEL (anhydrous); 25 mg/m3 STE (anhydrous) United States OSHA: 50 ppm TWA; 35 mg/m3 TWA Belgium - TWA: 20 ppm VLE; 14 mg/m3 VLE Belgium - STEL: 50 ppm VLE; 36 mg/m3 VLE France - VME: 25 ppm VME; 18 mg/m3 VME France - VLE: 50 ppm VLE; 36 mg/m3 VLE Germany: 50 ppm TWA; 35 mg/m3 TWA Japan: 25 ppm OEL; 17 mg/m3 OEL Malaysia: 25 ppm TWA; 17 mg/m3 TWA Netherlands: 50 ppm STEL; 36 mg/m3 STEL Netherlands: 20 ppm MAC; 14 mg/m3 MAC Russia: 20 mg/m3 TWA Spain: 20 ppm VLA-ED; 14 mg/m3 VLA-ED Spain: 50 ppm VLA-EC; 36 mg/m3 VLA-EC Personal Protective Equipment Eyes: Wear chemical splash goggles.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
A respiratory protection program that meets OSHAs 29 CFR 1910.134 and ANSI Z88.2 requirements or European Standard EN 149 must be followed whenever workplace conditions warrant respirator use.
Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Liquid
Color: clear, colorless
Odor: ammonia-like - alcohol-like
pH: Not available.
Vapor Pressure: Not available.
Viscosity: Not available.
Boiling Point: Not available.
Freezing/Melting Point: Not available.
Autoignition Temperature: Not applicable.
Flash Point: 11 deg C ( 51.80 deg F)
Explosion Limits, lower: Not available.
Explosion Limits, upper: Not available.
Decomposition Temperature:
Solubility in water:
Specific Gravity/Density: 0.7700g/cm3
Molecular Formula: H3N
Molecular Weight: 17.02
Section 10 - STABILITY AND REACTIVITY
Chemical Stability:
Stable under normal temperatures and pressures.
Conditions to Avoid:
High temperatures, ignition sources, moist air, confined spaces.
Incompatibilities with Other Materials:
Strong oxidizing agents, strong acids, powdered aluminum, powdered magnesium.
Hazardous Decomposition Products:
Carbon monoxide, irritating and toxic fumes and gases, carbon dioxide, formaldehyde.
Hazardous Polymerization: Has not been reported
Stable under normal temperatures and pressures.
Conditions to Avoid:
High temperatures, ignition sources, moist air, confined spaces.
Incompatibilities with Other Materials:
Strong oxidizing agents, strong acids, powdered aluminum, powdered magnesium.
Hazardous Decomposition Products:
Carbon monoxide, irritating and toxic fumes and gases, carbon dioxide, formaldehyde.
Hazardous Polymerization: Has not been reported
Section 11 - TOXICOLOGICAL INFORMATION
RTECS#:
CAS# 67-56-1: PC1400000 CAS# 7664-41-7: BO0875000 LD50/LC50:
CAS# 67-56-1: Draize test, rabbit, eye: 40 mg Moderate; Draize test, rabbit, eye: 100 mg/24H Moderate; Draize test, rabbit, skin: 20 mg/24H Moderate; Inhalation, rabbit: LC50 = 81000 mg/m3/14H; Inhalation, rat: LC50 = 64000 ppm/4H; Oral, mouse: LD50 = 7300 mg/kg; Oral, rabbit: LD50 = 14200 mg/kg; Oral, rat: LD50 = 5600 mg/kg; Skin, rabbit: LD50 = 15800 mg/kg.
CAS# 7664-41-7: Inhalation, mouse: LC50 = 4230 ppm/1H; Inhalation, mouse: LC50 = 4600 mg/m3/2H; Inhalation, rabbit: LC50 = 7 gm/m3/1H; Inhalation, rat: LC50 = 2000 ppm/4H; Inhalation, rat: LC50 = 18600 mg/m3/5M; Inhalation, rat: LC50 = 7040 mg/m3/30M; Skin, rat: LD50 = 112000 mg/m3/15M; Skin, rat: LD50 = 71900 mg/m3/30M; Skin, rat: LD50 = 4840 mg/m3/60M.
Carcinogenicity:
Methyl alcohol - Not listed by ACGIH, IARC, or NTP.
Ammonia - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
CAS# 67-56-1: PC1400000 CAS# 7664-41-7: BO0875000 LD50/LC50:
CAS# 67-56-1: Draize test, rabbit, eye: 40 mg Moderate; Draize test, rabbit, eye: 100 mg/24H Moderate; Draize test, rabbit, skin: 20 mg/24H Moderate; Inhalation, rabbit: LC50 = 81000 mg/m3/14H; Inhalation, rat: LC50 = 64000 ppm/4H; Oral, mouse: LD50 = 7300 mg/kg; Oral, rabbit: LD50 = 14200 mg/kg; Oral, rat: LD50 = 5600 mg/kg; Skin, rabbit: LD50 = 15800 mg/kg.
CAS# 7664-41-7: Inhalation, mouse: LC50 = 4230 ppm/1H; Inhalation, mouse: LC50 = 4600 mg/m3/2H; Inhalation, rabbit: LC50 = 7 gm/m3/1H; Inhalation, rat: LC50 = 2000 ppm/4H; Inhalation, rat: LC50 = 18600 mg/m3/5M; Inhalation, rat: LC50 = 7040 mg/m3/30M; Skin, rat: LD50 = 112000 mg/m3/15M; Skin, rat: LD50 = 71900 mg/m3/30M; Skin, rat: LD50 = 4840 mg/m3/60M.
Carcinogenicity:
Methyl alcohol - Not listed by ACGIH, IARC, or NTP.
Ammonia - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
Section 12 - ECOLOGICAL INFORMATION
Ecotoxicity:
Fish: Fathead Minnow: 29.4 g/L; 96 Hr; LC50 (unspecified)Fish: Goldfish: 250 ppm; 11 Hr; resulted in deathFish: Rainbow trout: 8000 mg/L; 48 Hr; LC50 (unspecified)Fish: Rainbow trout: LC50 = 13-68 mg/L; 96 Hr.; 12 degrees CFish: Fathead Minnow: LC50 = 29400 mg/L; 96 Hr.; 25 degrees C, pH 7.63Fish: Rainbow trout: LC50 = 8000 mg/L; 48 Hr.; UnspecifiedBacteria: Phytobacterium phosphoreum: EC50 = 51,000-320,000 mg/L; 30 minutes; Microtox test
Fish: Fathead Minnow: 29.4 g/L; 96 Hr; LC50 (unspecified)Fish: Goldfish: 250 ppm; 11 Hr; resulted in deathFish: Rainbow trout: 8000 mg/L; 48 Hr; LC50 (unspecified)Fish: Rainbow trout: LC50 = 13-68 mg/L; 96 Hr.; 12 degrees CFish: Fathead Minnow: LC50 = 29400 mg/L; 96 Hr.; 25 degrees C, pH 7.63Fish: Rainbow trout: LC50 = 8000 mg/L; 48 Hr.; UnspecifiedBacteria: Phytobacterium phosphoreum: EC50 = 51,000-320,000 mg/L; 30 minutes; Microtox test
Section 13 - DISPOSAL CONSIDERATIONS
Dispose of in a manner consistent with federal, state, and local regulations.
Section 14 - TRANSPORT INFORMATION
IATA
Shipping Name: FLAMMABLE LIQUID, TOXIC, CORROSIVE, N.O.S.*
Hazard Class: 3 (6.1)
UN Number: 3286
Packing Group: II
IMO
Shipping Name: FLAMMABLE LIQUID, TOXIC, CORROSIVE, N.O.S.
Hazard Class: 3.2 (6.1)
UN Number: 3286
Packing Group: II
RID/ADR
Shipping Name: FLAMMABLE LIQUID, TOXIC, CORROSIVE, N.O.S.
Hazard Class: 3 (6.1)
UN Number: 3286
Packing group: II
USA RQ: CAS# 67-56-1: 5000 lb final RQ; 2270 kg final RQ
USA RQ: CAS# 7664-41-7: 100 lb final RQ; 45.4 kg final RQ
Section 15 - REGULATORY INFORMATION
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: T F C
Risk Phrases:
R 11 Highly flammable.
R 23/24/25 Toxic by inhalation, in contact with skin
and if swallowed.
R 34 Causes burns.
R 39/23/24/25 Toxic : danger of very serious
irreversible effects through inhalation, in contact
with skin and if swallowed.
Safety Phrases:
S 7 Keep container tightly closed.
S 16 Keep away from sources of ignition - No
smoking.
S 26 In case of contact with eyes, rinse immediately
with plenty of water and seek medical advice.
S 36/37/39 Wear suitable protective clothing, gloves
and eye/face protection.
S 45 In case of accident or if you feel unwell, seek
medical advice immediately (show the label where
possible).
WGK (Water Danger/Protection)
CAS# 67-56-1: 1
CAS# 7664-41-7: 2
Canada
CAS# 67-56-1 is listed on Canadas DSL List.
CAS# 7664-41-7 is listed on Canadas DSL List.
CAS# 67-56-1 is listed on Canadas Ingredient Disclosure List.
CAS# 7664-41-7 is listed on Canadas Ingredient Disclosure List.
US FEDERAL
TSCA
CAS# 67-56-1 is listed on the TSCA inventory.
CAS# 7664-41-7 is listed on the TSCA inventory.
