Name:
Chlorotitanium triisopropoxide 1.0M solution in dichloromethane
Synonym:
Chlorotriisopropyloxytitane
CAS:
75-09-2
Section 1 - Chemical Product
MSDS Name:Chlorotitanium triisopropoxide 1.0M solution in dichloromethane
Synonym:Chlorotriisopropyloxytitane
Synonym:Chlorotriisopropyloxytitane
Section 2 - COMPOSITION, INFORMATION ON INGREDIENTS
| CAS# | Chemical Name | emsds | EINECS# |
| 75-09-2 | Methylene chloride | 74 | 200-838-9 |
| Hazard Symbols: C Risk Phrases: 34 |
Section 3 - HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
Causes burns.Corrosive.
Potential Health Effects
Eye:
Causes eye burns.
Skin:
Causes skin burns.
Ingestion:
May cause severe and permanent damage to the digestive tract. Causes gastrointestinal tract burns.
Inhalation:
Causes chemical burns to the respiratory tract. Vapors may cause dizziness or suffocation.
Chronic:
No information found.
Causes burns.Corrosive.
Potential Health Effects
Eye:
Causes eye burns.
Skin:
Causes skin burns.
Ingestion:
May cause severe and permanent damage to the digestive tract. Causes gastrointestinal tract burns.
Inhalation:
Causes chemical burns to the respiratory tract. Vapors may cause dizziness or suffocation.
Chronic:
No information found.
Section 4 - FIRST AID MEASURES
Eyes: Flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid immediately. Do NOT allow victim to rub eyes or keep eyes closed.
Extensive irrigation with water is required (at least 30 minutes).
Skin:
Get medical aid. Immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Wash clothing before reuse. Discard contaminated clothing in a manner which limits further exposure. Destroy contaminated shoes.
Ingestion:
Do not induce vomiting. If victim is conscious and alert, give 2-4 cupfuls of milk or water. Never give anything by mouth to an unconscious person. Get medical aid immediately.
Inhalation:
Get medical aid immediately. Remove from exposure and move to fresh air immediately. If breathing is difficult, give oxygen. Do NOT use mouth-to-mouth resuscitation. If breathing has ceased apply artificial respiration using oxygen and a suitable mechanical device such as a bag and a mask.
Notes to Physician:
Antidote: None reported.
Extensive irrigation with water is required (at least 30 minutes).
Skin:
Get medical aid. Immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Wash clothing before reuse. Discard contaminated clothing in a manner which limits further exposure. Destroy contaminated shoes.
Ingestion:
Do not induce vomiting. If victim is conscious and alert, give 2-4 cupfuls of milk or water. Never give anything by mouth to an unconscious person. Get medical aid immediately.
Inhalation:
Get medical aid immediately. Remove from exposure and move to fresh air immediately. If breathing is difficult, give oxygen. Do NOT use mouth-to-mouth resuscitation. If breathing has ceased apply artificial respiration using oxygen and a suitable mechanical device such as a bag and a mask.
Notes to Physician:
Antidote: None reported.
Section 5 - FIRE FIGHTING MEASURES
General Information:
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. Substance is noncombustible.
Extinguishing Media:
Use water spray, dry chemical, carbon dioxide, or appropriate foam.
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. Substance is noncombustible.
Extinguishing Media:
Use water spray, dry chemical, carbon dioxide, or appropriate foam.
Section 6 - ACCIDENTAL RELEASE MEASURES
General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks:
Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in suitable container. Clean up spills immediately, observing precautions in the Protective Equipment section. Provide ventilation.
Spills/Leaks:
Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in suitable container. Clean up spills immediately, observing precautions in the Protective Equipment section. Provide ventilation.
Section 7 - HANDLING and STORAGE
Handling:
Do not get in eyes, on skin, or on clothing. Keep container tightly closed. Do not ingest or inhale. Use with adequate ventilation.
Discard contaminated shoes.
Storage:
Keep container closed when not in use. Store in a cool, dry, well-ventilated area away from incompatible substances. Corrosives area.
Do not get in eyes, on skin, or on clothing. Keep container tightly closed. Do not ingest or inhale. Use with adequate ventilation.
Discard contaminated shoes.
Storage:
Keep container closed when not in use. Store in a cool, dry, well-ventilated area away from incompatible substances. Corrosives area.
Section 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION
Engineering Controls:
Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use adequate ventilation to keep airborne concentrations low.
Exposure Limits CAS# 75-09-2: United Kingdom, WEL - TWA: 100 ppm TWA; 350 mg/m3 TWA United Kingdom, WEL - STEL: 300 ppm STEL; 1060 mg/m3 STEL United States OSHA: ; 25 ppm TWA (8 hr); 125 ppm STEL (15 min); 1 ppm Action Level (See 29 CFR 1910 .1052) Belgium - TWA: 50 ppm VLE; 177 mg/m3 VLE France - VME: 50 ppm VME; 180 mg/m3 VME France - VLE: 100 ppm VLE; 350 mg/m3 VLE Germany: 100 ppm TWA; 350 mg/m3 TWA Japan: 50 ppm OEL; 170 mg/m3 OEL Japan: 100 ppm Ceiling; 340 mg/m3 Ceiling Malaysia: 50 ppm TWA Netherlands: 500 ppm STEL; 1750 mg/m3 STEL Netherlands: 100 ppm MAC; 350 mg/m3 MAC Russia: 50 mg/m3 TWA Spain: 50 ppm VLA-ED; 177 mg/m3 VLA-ED CAS# 20717-86-6: Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHAs eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced.
Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use adequate ventilation to keep airborne concentrations low.
Exposure Limits CAS# 75-09-2: United Kingdom, WEL - TWA: 100 ppm TWA; 350 mg/m3 TWA United Kingdom, WEL - STEL: 300 ppm STEL; 1060 mg/m3 STEL United States OSHA: ; 25 ppm TWA (8 hr); 125 ppm STEL (15 min); 1 ppm Action Level (See 29 CFR 1910 .1052) Belgium - TWA: 50 ppm VLE; 177 mg/m3 VLE France - VME: 50 ppm VME; 180 mg/m3 VME France - VLE: 100 ppm VLE; 350 mg/m3 VLE Germany: 100 ppm TWA; 350 mg/m3 TWA Japan: 50 ppm OEL; 170 mg/m3 OEL Japan: 100 ppm Ceiling; 340 mg/m3 Ceiling Malaysia: 50 ppm TWA Netherlands: 500 ppm STEL; 1750 mg/m3 STEL Netherlands: 100 ppm MAC; 350 mg/m3 MAC Russia: 50 mg/m3 TWA Spain: 50 ppm VLA-ED; 177 mg/m3 VLA-ED CAS# 20717-86-6: Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHAs eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced.
Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Viscous liquid
Color: colourless
Odor: None reported.
pH: Not available.
Vapor Pressure: Not available.
Viscosity: Not available.
Boiling Point: Not available.
Freezing/Melting Point: 0 deg C
Autoignition Temperature: 240 deg C ( 464.00 deg F)
Flash Point: None
Explosion Limits, lower: Not available.
Explosion Limits, upper: Not available.
Decomposition Temperature:
Solubility in water:
Specific Gravity/Density: .7750g/cm3
Molecular Formula: C9H21ClO3Ti
Molecular Weight: 260.59
Section 10 - STABILITY AND REACTIVITY
Chemical Stability:
Stable under normal temperatures and pressures. May decompose on exposure to moist air or water.
Conditions to Avoid:
Incompatible materials, ignition sources, excess heat, strong oxidants.
Incompatibilities with Other Materials:
Strong oxidizing agents.
Hazardous Decomposition Products:
Hydrogen chloride, carbon monoxide, irritating and toxic fumes and gases, carbon dioxide, titanium/titanium oxides.
Hazardous Polymerization: Has not been reported.
Stable under normal temperatures and pressures. May decompose on exposure to moist air or water.
Conditions to Avoid:
Incompatible materials, ignition sources, excess heat, strong oxidants.
Incompatibilities with Other Materials:
Strong oxidizing agents.
Hazardous Decomposition Products:
Hydrogen chloride, carbon monoxide, irritating and toxic fumes and gases, carbon dioxide, titanium/titanium oxides.
Hazardous Polymerization: Has not been reported.
Section 11 - TOXICOLOGICAL INFORMATION
RTECS#:
CAS# 75-09-2: PA8050000 CAS# 20717-86-6 unlisted.
LD50/LC50:
CAS# 75-09-2: Draize test, rabbit, eye: 162 mg Moderate; Draize test, rabbit, eye: 10 mg Mild; Draize test, rabbit, eye: 500 mg/24H Mild; Draize test, rabbit, skin: 810 mg/24H Severe; Draize test, rabbit, skin: 100 mg/24H Moderate; Inhalation, mouse: LC50 = 14400 ppm/7H; Inhalation, mouse: LC50 = 49100 mg/m3/6H; Inhalation, mouse: LC50 = 54000 mg/m3/2H; Inhalation, mouse: LC50 = 56220 mg/m3/7H; Inhalation, rat: LC50 = 52 gm/m3; Inhalation, rat: LC50 = 76000 mg/m3/4H; Inhalation, rat: LC50 = 52000 mg/m3/6H; Oral, mouse: LD50 = 873 mg/kg; Oral, rabbit: LD50 = 2000 mg/kg; Oral, rat: LD50 = 1600 mg/kg; Oral, rat: LD50 = 985 mg/kg.
CAS# 20717-86-6.
Carcinogenicity:
Methylene chloride - ACGIH: A3 - Confirmed animal carcinogen with unknown relevance to California: carcinogen, initial date 4/1/88 NTP: Suspect carcinogen IARC: Group 2B carcinogen Chlorotitanium triisopropoxide - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
CAS# 75-09-2: PA8050000 CAS# 20717-86-6 unlisted.
LD50/LC50:
CAS# 75-09-2: Draize test, rabbit, eye: 162 mg Moderate; Draize test, rabbit, eye: 10 mg Mild; Draize test, rabbit, eye: 500 mg/24H Mild; Draize test, rabbit, skin: 810 mg/24H Severe; Draize test, rabbit, skin: 100 mg/24H Moderate; Inhalation, mouse: LC50 = 14400 ppm/7H; Inhalation, mouse: LC50 = 49100 mg/m3/6H; Inhalation, mouse: LC50 = 54000 mg/m3/2H; Inhalation, mouse: LC50 = 56220 mg/m3/7H; Inhalation, rat: LC50 = 52 gm/m3; Inhalation, rat: LC50 = 76000 mg/m3/4H; Inhalation, rat: LC50 = 52000 mg/m3/6H; Oral, mouse: LD50 = 873 mg/kg; Oral, rabbit: LD50 = 2000 mg/kg; Oral, rat: LD50 = 1600 mg/kg; Oral, rat: LD50 = 985 mg/kg.
CAS# 20717-86-6.
Carcinogenicity:
Methylene chloride - ACGIH: A3 - Confirmed animal carcinogen with unknown relevance to California: carcinogen, initial date 4/1/88 NTP: Suspect carcinogen IARC: Group 2B carcinogen Chlorotitanium triisopropoxide - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
Section 12 - ECOLOGICAL INFORMATION
Other No information available.
Section 13 - DISPOSAL CONSIDERATIONS
Dispose of in a manner consistent with federal, state, and local regulations.
Section 14 - TRANSPORT INFORMATION
IATA
Shipping Name: CORROSIVE LIQUID, N.O.S.*
Hazard Class: 8
UN Number: 1760
Packing Group: II
IMO
Shipping Name: CORROSIVE LIQUID, N.O.S.
Hazard Class: 8
UN Number: 1760
Packing Group: II
RID/ADR
Shipping Name: CORROSIVE LIQUID, N.O.S.
Hazard Class: 8
UN Number: 1760
Packing group: II
USA RQ: CAS# 75-09-2: 1000 lb final RQ; 454 kg final RQ
Section 15 - REGULATORY INFORMATION
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: C
Risk Phrases:
R 34 Causes burns.
Safety Phrases:
S 9 Keep container in a well-ventilated place.
S 16 Keep away from sources of ignition - No
smoking.
S 23 Do not inhale gas/fumes/vapour/spray.
S 24/25 Avoid contact with skin and eyes.
S 29 Do not empty into drains.
S 33 Take precautionary measures against static
discharges.
S 50A Do not mix with acids.
WGK (Water Danger/Protection)
CAS# 75-09-2: 2
CAS# 20717-86-6: No information available.
Canada
CAS# 75-09-2 is listed on Canadas DSL List.
CAS# 75-09-2 is listed on Canadas Ingredient Disclosure List.
CAS# 20717-86-6 is not listed on Canadas Ingredient Disclosure List.
US FEDERAL
TSCA
CAS# 75-09-2 is listed on the TSCA inventory.
CAS# 20717-86-6 is listed on the TSCA inventory.
