Name:
Electrolyte Formulation TC-A
Synonym:
None Known
CAS:
7446-70-0
Section 1 - Chemical Product
MSDS Name:Electrolyte Formulation TC-A
Synonym:None Known
Synonym:None Known
Section 2 - COMPOSITION, INFORMATION ON INGREDIENTS
| CAS# | Chemical Name | emsds | EINECS# |
| 7446-70-0 | Aluminum chloride | 11 | 231-208-1 |
| Hazard Symbols: C Risk Phrases: 14 20/22 29 35 |
Section 3 - HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
Reacts violently with water. Harmful by inhalation and if swallowed.
Contact with water liberates toxic gas. Causes severe burns.Corrosive.Lachrymator (substance which increases the flow of tears).Water-reactive.Light sensitive.
Potential Health Effects
Eye:
Causes eye burns. Causes redness and pain. Lachrymator (substance which increases the flow of tears).
Skin:
Causes skin burns. May be absorbed through the skin in harmful amounts. Causes redness and pain.
Ingestion:
Harmful if swallowed. May cause severe and permanent damage to the digestive tract. Causes gastrointestinal tract burns.
Inhalation:
Harmful if inhaled. Causes chemical burns to the respiratory tract.
Inhalation may be fatal as a result of spasm, inflammation, edema of the larynx and bronchi, chemical pneumonitis and pulmonary edema.
Chronic:
No information found.
Reacts violently with water. Harmful by inhalation and if swallowed.
Contact with water liberates toxic gas. Causes severe burns.Corrosive.Lachrymator (substance which increases the flow of tears).Water-reactive.Light sensitive.
Potential Health Effects
Eye:
Causes eye burns. Causes redness and pain. Lachrymator (substance which increases the flow of tears).
Skin:
Causes skin burns. May be absorbed through the skin in harmful amounts. Causes redness and pain.
Ingestion:
Harmful if swallowed. May cause severe and permanent damage to the digestive tract. Causes gastrointestinal tract burns.
Inhalation:
Harmful if inhaled. Causes chemical burns to the respiratory tract.
Inhalation may be fatal as a result of spasm, inflammation, edema of the larynx and bronchi, chemical pneumonitis and pulmonary edema.
Chronic:
No information found.
Section 4 - FIRST AID MEASURES
Eyes: Get medical aid immediately. Do NOT allow victim to rub eyes or keep eyes closed. Extensive irrigation with water is required (at least 30 minutes).
Skin:
Get medical aid immediately. Immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes. Wash clothing before reuse. Destroy contaminated shoes.
Ingestion:
Do not induce vomiting. If victim is conscious and alert, give 2-4 cupfuls of milk or water. Never give anything by mouth to an unconscious person. Get medical aid immediately.
Inhalation:
Get medical aid immediately. Remove from exposure and move to fresh air immediately. If breathing is difficult, give oxygen. Do NOT use mouth-to-mouth resuscitation. If breathing has ceased apply artificial respiration using oxygen and a suitable mechanical device such as a bag and a mask.
Notes to Physician:
Skin:
Get medical aid immediately. Immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes. Wash clothing before reuse. Destroy contaminated shoes.
Ingestion:
Do not induce vomiting. If victim is conscious and alert, give 2-4 cupfuls of milk or water. Never give anything by mouth to an unconscious person. Get medical aid immediately.
Inhalation:
Get medical aid immediately. Remove from exposure and move to fresh air immediately. If breathing is difficult, give oxygen. Do NOT use mouth-to-mouth resuscitation. If breathing has ceased apply artificial respiration using oxygen and a suitable mechanical device such as a bag and a mask.
Notes to Physician:
Section 5 - FIRE FIGHTING MEASURES
General Information:
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. Water Reactive. Material will react with water and may release a flammable and/or toxic gas. Containers may explode in the heat of a fire. Vapors may be heavier than air. They can spread along the ground and collect in low or confined areas. Contact with metals may evolve flammable hydrogen gas.
Extinguishing Media:
Do NOT use water directly on fire. If water is the only media available, use in flooding amounts. Do NOT get water inside containers. Use dry chemical or carbon dioxide.
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. Water Reactive. Material will react with water and may release a flammable and/or toxic gas. Containers may explode in the heat of a fire. Vapors may be heavier than air. They can spread along the ground and collect in low or confined areas. Contact with metals may evolve flammable hydrogen gas.
Extinguishing Media:
Do NOT use water directly on fire. If water is the only media available, use in flooding amounts. Do NOT get water inside containers. Use dry chemical or carbon dioxide.
Section 6 - ACCIDENTAL RELEASE MEASURES
General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks:
Avoid runoff into storm sewers and ditches which lead to waterways.
Clean up spills immediately, observing precautions in the Protective Equipment section. Use a spark-proof tool. Do not get water inside containers. Cover with dry earth, dry sand, or other non-combustible material followed with plastic sheet to minimize spreading and contact with water.
Spills/Leaks:
Avoid runoff into storm sewers and ditches which lead to waterways.
Clean up spills immediately, observing precautions in the Protective Equipment section. Use a spark-proof tool. Do not get water inside containers. Cover with dry earth, dry sand, or other non-combustible material followed with plastic sheet to minimize spreading and contact with water.
Section 7 - HANDLING and STORAGE
Handling:
Keep container tightly closed. Do not get on skin or in eyes. Do not ingest or inhale. Use with adequate ventilation. Store protected from light. Do not allow contact with water. Discard contaminated shoes.
Storage:
Keep container closed when not in use. Store in a cool, dry, well-ventilated area away from incompatible substances. Keep away from water. Corrosives area. Keep away from acids. Do not store in metal containers. Store protected from light.
Keep container tightly closed. Do not get on skin or in eyes. Do not ingest or inhale. Use with adequate ventilation. Store protected from light. Do not allow contact with water. Discard contaminated shoes.
Storage:
Keep container closed when not in use. Store in a cool, dry, well-ventilated area away from incompatible substances. Keep away from water. Corrosives area. Keep away from acids. Do not store in metal containers. Store protected from light.
Section 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION
Engineering Controls:
Use process enclosure, local exhaust ventilation, or other engineering controls to control airborne levels below recommended exposure limits. Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use only under a chemical fume hood.
Exposure Limits CAS# 7446-70-0: United Kingdom, WEL - TWA: (listed as aluminum, soluble salts): 2 mg/m3 TWA United Kingdom, WEL - STEL: (listed as aluminum, soluble salts): mg/m3 STEL Belgium - TWA: (listed as aluminum, soluble salts): 2 mg/m3 VLE ( Al) France - VME: (listed as aluminum, soluble salts): 2 mg/m3 VME Germany: (listed as aluminum, soluble salts): 2 mg/m3 VME Malaysia: (listed as aluminum, soluble salts): 2 mg/m3 TWA (as Al Spain: (listed as aluminum, soluble salts): 2 mg/m3 VLA-ED (as Al CAS# 7447-41-8: CAS# 7719-09-7: United Kingdom, WEL - STEL: 1 ppm STEL; 4.9 mg/m3 STEL Malaysia: 1 ppm Ceiling; 4.9 mg/m3 Ceiling Spain: 1 ppm VLA-EC; 4.9 mg/m3 VLA-EC Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHAs eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear nitrile-latex gloves, apron, and/or clothing.
Clothing:
Wear nitrile-latex gloves, apron, and/or clothing.
Respirators:
A respiratory protection program that meets OSHAs 29 CFR 1910.134 and ANSI Z88.2 requirements or European Standard EN 149 must be followed whenever workplace conditions warrant respirator use.
Use process enclosure, local exhaust ventilation, or other engineering controls to control airborne levels below recommended exposure limits. Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use only under a chemical fume hood.
Exposure Limits CAS# 7446-70-0: United Kingdom, WEL - TWA: (listed as aluminum, soluble salts): 2 mg/m3 TWA United Kingdom, WEL - STEL: (listed as aluminum, soluble salts): mg/m3 STEL Belgium - TWA: (listed as aluminum, soluble salts): 2 mg/m3 VLE ( Al) France - VME: (listed as aluminum, soluble salts): 2 mg/m3 VME Germany: (listed as aluminum, soluble salts): 2 mg/m3 VME Malaysia: (listed as aluminum, soluble salts): 2 mg/m3 TWA (as Al Spain: (listed as aluminum, soluble salts): 2 mg/m3 VLA-ED (as Al CAS# 7447-41-8: CAS# 7719-09-7: United Kingdom, WEL - STEL: 1 ppm STEL; 4.9 mg/m3 STEL Malaysia: 1 ppm Ceiling; 4.9 mg/m3 Ceiling Spain: 1 ppm VLA-EC; 4.9 mg/m3 VLA-EC Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHAs eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear nitrile-latex gloves, apron, and/or clothing.
Clothing:
Wear nitrile-latex gloves, apron, and/or clothing.
Respirators:
A respiratory protection program that meets OSHAs 29 CFR 1910.134 and ANSI Z88.2 requirements or European Standard EN 149 must be followed whenever workplace conditions warrant respirator use.
Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Liquid
Color: colorless to slight yellow
Odor: Not available.
pH: Not available.
Vapor Pressure: Not available.
Viscosity: Not available.
Boiling Point: Not available.
Freezing/Melting Point: Not available.
Autoignition Temperature: Not available.
Flash Point: Not available.
Explosion Limits, lower: Not available.
Explosion Limits, upper: Not available.
Decomposition Temperature:
Solubility in water:
Specific Gravity/Density:
Molecular Formula: Solution
Molecular Weight: 0
Section 10 - STABILITY AND REACTIVITY
Chemical Stability:
Reacts violently with water to form the toxic gases hydrogen chloride and sulfur dioxide.
Conditions to Avoid:
Light, contact with water, acids, metals, alkaline materials, temperatures above 140C.
Incompatibilities with Other Materials:
Alkalies, ammonia, dimethyl formamide, dimethyl sulfoxide, lithium, metals, sodium, water, acids, bases, amines, alcohols, aluminum.
Hazardous Decomposition Products:
Hydrogen chloride, chlorine, oxides of sulfur.
Hazardous Polymerization: Will not occur.
Reacts violently with water to form the toxic gases hydrogen chloride and sulfur dioxide.
Conditions to Avoid:
Light, contact with water, acids, metals, alkaline materials, temperatures above 140C.
Incompatibilities with Other Materials:
Alkalies, ammonia, dimethyl formamide, dimethyl sulfoxide, lithium, metals, sodium, water, acids, bases, amines, alcohols, aluminum.
Hazardous Decomposition Products:
Hydrogen chloride, chlorine, oxides of sulfur.
Hazardous Polymerization: Will not occur.
Section 11 - TOXICOLOGICAL INFORMATION
RTECS#:
CAS# 7446-70-0: BD0525000 CAS# 7447-41-8: OJ5950000 CAS# 7719-09-7: XM5150000 LD50/LC50:
CAS# 7446-70-0: Draize test, rabbit, skin: 10%/6D (Intermittent); Oral, mouse: LD50 = 1130 mg/kg; Oral, rat: LD50 = 3450 mg/kg; Skin, rabbit: LD50 = >2 gm/kg.
CAS# 7447-41-8: Draize test, rabbit, eye: 100 mg/24H Moderate; Draize test, rabbit, skin: 500 mg/24H Severe; Oral, mouse: LD50 = 1165 mg/kg; Oral, mouse: LD50 = 1165 mg/kg; Oral, rabbit: LD50 = 800 mg/kg; Oral, rabbit: LD50 = 775 mg/kg; Oral, rat: LD50 = 526 mg/kg; Oral, rat: LD50 = 1530 mg/kg; Skin, rabbit: LD50 = 1629 mg/kg; Skin, rat: LD50 = 1488 mg/kg.
CAS# 7719-09-7: Inhalation, rat: LC50 = 500 ppm/1H.
Carcinogenicity:
Aluminum chloride - Not listed by ACGIH, IARC, or NTP.
Lithium chloride - Not listed by ACGIH, IARC, or NTP.
Thionyl chloride - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
CAS# 7446-70-0: BD0525000 CAS# 7447-41-8: OJ5950000 CAS# 7719-09-7: XM5150000 LD50/LC50:
CAS# 7446-70-0: Draize test, rabbit, skin: 10%/6D (Intermittent); Oral, mouse: LD50 = 1130 mg/kg; Oral, rat: LD50 = 3450 mg/kg; Skin, rabbit: LD50 = >2 gm/kg.
CAS# 7447-41-8: Draize test, rabbit, eye: 100 mg/24H Moderate; Draize test, rabbit, skin: 500 mg/24H Severe; Oral, mouse: LD50 = 1165 mg/kg; Oral, mouse: LD50 = 1165 mg/kg; Oral, rabbit: LD50 = 800 mg/kg; Oral, rabbit: LD50 = 775 mg/kg; Oral, rat: LD50 = 526 mg/kg; Oral, rat: LD50 = 1530 mg/kg; Skin, rabbit: LD50 = 1629 mg/kg; Skin, rat: LD50 = 1488 mg/kg.
CAS# 7719-09-7: Inhalation, rat: LC50 = 500 ppm/1H.
Carcinogenicity:
Aluminum chloride - Not listed by ACGIH, IARC, or NTP.
Lithium chloride - Not listed by ACGIH, IARC, or NTP.
Thionyl chloride - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
Section 12 - ECOLOGICAL INFORMATION
Section 13 - DISPOSAL CONSIDERATIONS
Products which are considered hazardous for supply are classified as Special Waste and the disposal of such chemicals is covered by regulations which may vary according to location. Contact a specialist disposal company or the local waste regulator for advice. Empty containers must be decontaminated before returning for recycling.
Section 14 - TRANSPORT INFORMATION
IATA
Shipping Name: FORBIDDEN BY AIR
Hazard Class:
UN Number: -
Packing Group:
IMO
Shipping Name: CORROSIVE LIQUID, ACIDIC, INORGANIC, N.O
Hazard Class: 8
UN Number: 3264
Packing Group: I
RID/ADR
Shipping Name: CORROSIVE LIQUID, ACIDIC, INORGANIC, N.O
Hazard Class: 8
UN Number: 3264
Packing group: I
Section 15 - REGULATORY INFORMATION
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: C
Risk Phrases:
R 14 Reacts violently with water.
R 20/22 Harmful by inhalation and if swallowed.
R 29 Contact with water liberates toxic gas.
R 35 Causes severe burns.
Safety Phrases:
S 26 In case of contact with eyes, rinse immediately
with plenty of water and seek medical advice.
S 28 After contact with skin, wash immediately
with...
S 36/37/39 Wear suitable protective clothing, gloves
and eye/face protection.
S 45 In case of accident or if you feel unwell, seek
medical advice immediately (show the label where
possible).
WGK (Water Danger/Protection)
CAS# 7446-70-0: 1
CAS# 7447-41-8: 1
CAS# 7719-09-7: 1
Canada
CAS# 7446-70-0 is listed on Canadas DSL List.
CAS# 7447-41-8 is listed on Canadas DSL List.
CAS# 7719-09-7 is listed on Canadas DSL List.
CAS# 7446-70-0 is listed on Canadas Ingredient Disclosure List.
CAS# 7447-41-8 is not listed on Canadas Ingredient Disclosure List.
CAS# 7719-09-7 is listed on Canadas Ingredient Disclosure List.
US FEDERAL
TSCA
CAS# 7446-70-0 is listed on the TSCA inventory.
CAS# 7447-41-8 is listed on the TSCA inventory.
CAS# 7719-09-7 is listed on the TSCA inventory.
