Name:
Manganese standard metal solution in approx. M nitric acid
Synonym:
None
CAS:
7439-96-5
Section 1 - Chemical Product
MSDS Name:Manganese standard metal solution in approx. M nitric acid
Synonym:None
Synonym:None
Section 2 - COMPOSITION, INFORMATION ON INGREDIENTS
| CAS# | Chemical Name | emsds | EINECS# |
| 7439-96-5 | Manganese | <1 | 231-105-1 |
| Hazard Symbols: C Risk Phrases: 34 |
Section 3 - HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
Causes burns.
Potential Health Effects
Eye:
Causes eye burns.
Skin:
Causes skin burns.
Ingestion:
May cause severe gastrointestinal tract irritation with nausea, vomiting and possible burns.
Inhalation:
May cause severe irritation of the respiratory tract with sore throat, coughing, shortness of breath and delayed lung edema.
Chronic:
Exposure to high concentrations of nitric acid vapor may cause pneuomonitis and pulmonary edema which may be fatal. Symptoms may or may not be delayed. Continued exposure to the vapor & mist of nitric acid may result in a chronic bronchitis, & more severe exposure results in a chemical pneumonitis. The vapor & mists of nitric acid may erode the teeth, particularly affecting the canines & incisors.
Causes burns.
Potential Health Effects
Eye:
Causes eye burns.
Skin:
Causes skin burns.
Ingestion:
May cause severe gastrointestinal tract irritation with nausea, vomiting and possible burns.
Inhalation:
May cause severe irritation of the respiratory tract with sore throat, coughing, shortness of breath and delayed lung edema.
Chronic:
Exposure to high concentrations of nitric acid vapor may cause pneuomonitis and pulmonary edema which may be fatal. Symptoms may or may not be delayed. Continued exposure to the vapor & mist of nitric acid may result in a chronic bronchitis, & more severe exposure results in a chemical pneumonitis. The vapor & mists of nitric acid may erode the teeth, particularly affecting the canines & incisors.
Section 4 - FIRST AID MEASURES
Eyes: Flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid immediately. Do NOT allow victim to rub eyes or keep eyes closed.
Skin:
Get medical aid immediately. Flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Wash clothing before reuse.
Ingestion:
Do not induce vomiting. If victim is conscious and alert, give 2-4 cupfuls of milk or water. Never give anything by mouth to an unconscious person. Get medical aid immediately.
Inhalation:
Remove from exposure and move to fresh air immediately. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical aid.
Notes to Physician:
Skin:
Get medical aid immediately. Flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Wash clothing before reuse.
Ingestion:
Do not induce vomiting. If victim is conscious and alert, give 2-4 cupfuls of milk or water. Never give anything by mouth to an unconscious person. Get medical aid immediately.
Inhalation:
Remove from exposure and move to fresh air immediately. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical aid.
Notes to Physician:
Section 5 - FIRE FIGHTING MEASURES
General Information:
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. Use water spray to keep fire-exposed containers cool. Substance is noncombustible.
Extinguishing Media:
Substance is noncombustible; use agent most appropriate to extinguish surrounding fire.
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. Use water spray to keep fire-exposed containers cool. Substance is noncombustible.
Extinguishing Media:
Substance is noncombustible; use agent most appropriate to extinguish surrounding fire.
Section 6 - ACCIDENTAL RELEASE MEASURES
General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks:
Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in suitable container. Wear a self contained breathing apparatus and appropriate personal protection. (See Exposure Controls, Personal Protection section). Neutralize spill with sodium bicarbonate. Use water spray to disperse the gas/vapor.
Spills/Leaks:
Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in suitable container. Wear a self contained breathing apparatus and appropriate personal protection. (See Exposure Controls, Personal Protection section). Neutralize spill with sodium bicarbonate. Use water spray to disperse the gas/vapor.
Section 7 - HANDLING and STORAGE
Handling:
Wash thoroughly after handling. Remove contaminated clothing and wash before reuse. Use with adequate ventilation. Do not get on skin or in eyes. Do not ingest or inhale. Discard contaminated shoes.
Storage:
Store in a cool, dry, well-ventilated area away from incompatible substances.
Wash thoroughly after handling. Remove contaminated clothing and wash before reuse. Use with adequate ventilation. Do not get on skin or in eyes. Do not ingest or inhale. Discard contaminated shoes.
Storage:
Store in a cool, dry, well-ventilated area away from incompatible substances.
Section 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION
Engineering Controls:
Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use adequate general or local exhaust ventilation to keep airborne concentrations below the permissible exposure limits.
Exposure Limits CAS# 7439-96-5: United Kingdom, WEL - TWA: 0.5 mg/m3 TWA United Kingdom, WEL - STEL: 1.5 mg/m3 STEL United States OSHA: ; 5 mg/m3 Ceiling (fume) Belgium - TWA: 0.2 mg/m3 VLE France - VME: 1 mg/m3 VME (fume, as Mn) Germany: 0.5 mg/m3 TWA (inhalable fraction) Japan: 0.3 mg/m3 OEL Malaysia: 0.2 mg/m3 TWA Netherlands: 3 mg/m3 STEL Netherlands: 1 mg/m3 MAC Russia: 0.2 mg/m3 TWA (fumes, share to 20%); 0.1 mg/m3 TWA (fumes share to 30%) Spain: 0.2 mg/m3 VLA-ED CAS# 7697-37-2: United Kingdom, WEL - TWA: 2 ppm TWA; 5.2 mg/m3 TWA United Kingdom, WEL - STEL: 4 ppm STEL; 10 mg/m3 STEL United States OSHA: 2 ppm TWA; 5 mg/m3 TWA Belgium - TWA: 2 ppm VLE; 5.3 mg/m3 VLE Belgium - STEL: 4 ppm VLE; 10 mg/m3 VLE France - VME: 2 ppm VME; 5 mg/m3 VME France - VLE: 4 ppm VLE; 10 mg/m3 VLE Germany: 2 ppm TWA; 5.2 mg/m3 TWA Japan: 2 ppm OEL; 5.2 mg/m3 OEL Malaysia: 2 ppm TWA; 5.2 mg/m3 TWA Netherlands: 0.5 ppm STEL; 1.3 mg/m3 STEL Russia: 2 mg/m3 TWA Spain: 2 ppm VLA-ED; 5.2 mg/m3 VLA-ED Spain: 4 ppm VLA-EC; 10 mg/m3 VLA-EC CAS# 7732-18-5: Personal Protective Equipment Eyes: Wear chemical splash goggles.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
A respiratory protection program that meets OSHAs 29 CFR 1910.134 and ANSI Z88.2 requirements or European Standard EN 149 must be followed whenever workplace conditions warrant respirator use.
Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use adequate general or local exhaust ventilation to keep airborne concentrations below the permissible exposure limits.
Exposure Limits CAS# 7439-96-5: United Kingdom, WEL - TWA: 0.5 mg/m3 TWA United Kingdom, WEL - STEL: 1.5 mg/m3 STEL United States OSHA: ; 5 mg/m3 Ceiling (fume) Belgium - TWA: 0.2 mg/m3 VLE France - VME: 1 mg/m3 VME (fume, as Mn) Germany: 0.5 mg/m3 TWA (inhalable fraction) Japan: 0.3 mg/m3 OEL Malaysia: 0.2 mg/m3 TWA Netherlands: 3 mg/m3 STEL Netherlands: 1 mg/m3 MAC Russia: 0.2 mg/m3 TWA (fumes, share to 20%); 0.1 mg/m3 TWA (fumes share to 30%) Spain: 0.2 mg/m3 VLA-ED CAS# 7697-37-2: United Kingdom, WEL - TWA: 2 ppm TWA; 5.2 mg/m3 TWA United Kingdom, WEL - STEL: 4 ppm STEL; 10 mg/m3 STEL United States OSHA: 2 ppm TWA; 5 mg/m3 TWA Belgium - TWA: 2 ppm VLE; 5.3 mg/m3 VLE Belgium - STEL: 4 ppm VLE; 10 mg/m3 VLE France - VME: 2 ppm VME; 5 mg/m3 VME France - VLE: 4 ppm VLE; 10 mg/m3 VLE Germany: 2 ppm TWA; 5.2 mg/m3 TWA Japan: 2 ppm OEL; 5.2 mg/m3 OEL Malaysia: 2 ppm TWA; 5.2 mg/m3 TWA Netherlands: 0.5 ppm STEL; 1.3 mg/m3 STEL Russia: 2 mg/m3 TWA Spain: 2 ppm VLA-ED; 5.2 mg/m3 VLA-ED Spain: 4 ppm VLA-EC; 10 mg/m3 VLA-EC CAS# 7732-18-5: Personal Protective Equipment Eyes: Wear chemical splash goggles.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
A respiratory protection program that meets OSHAs 29 CFR 1910.134 and ANSI Z88.2 requirements or European Standard EN 149 must be followed whenever workplace conditions warrant respirator use.
Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Liquid
Color: colorless
Odor: Not available.
pH: Not available.
Vapor Pressure: Not available.
Viscosity: Not available.
Boiling Point: Not available.
Freezing/Melting Point: Not available.
Autoignition Temperature: Not available.
Flash Point: Not available.
Explosion Limits, lower: Not available.
Explosion Limits, upper: Not available.
Decomposition Temperature: Not available.
Solubility in water: Soluble in water.
Specific Gravity/Density: 1.0
Molecular Formula: Solution
Molecular Weight: 0
Section 10 - STABILITY AND REACTIVITY
Chemical Stability:
Stable at room temperature in closed containers under normal storage and handling conditions.
Conditions to Avoid:
Confined spaces.
Incompatibilities with Other Materials:
Nitric acid reacts with over 150 chemical combinations. Refer to NFPA Fire Protection Guide for specifics. Reacts explosively with organic materials and combustibles.
Hazardous Decomposition Products:
Nitrogen oxides.
Hazardous Polymerization: Has not been reported
Stable at room temperature in closed containers under normal storage and handling conditions.
Conditions to Avoid:
Confined spaces.
Incompatibilities with Other Materials:
Nitric acid reacts with over 150 chemical combinations. Refer to NFPA Fire Protection Guide for specifics. Reacts explosively with organic materials and combustibles.
Hazardous Decomposition Products:
Nitrogen oxides.
Hazardous Polymerization: Has not been reported
Section 11 - TOXICOLOGICAL INFORMATION
RTECS#:
CAS# 7439-96-5: OO9275000 CAS# 7697-37-2: QU5775000 QU5900000 CAS# 7732-18-5: ZC0110000 LD50/LC50:
CAS# 7439-96-5: Draize test, rabbit, eye: 500 mg/24H Mild; Draize test, rabbit, skin: 500 mg/24H Mild; Oral, rat: LD50 = 9 gm/kg.
CAS# 7697-37-2: Inhalation, rat: LC50 = 260 mg/m3/30M; Inhalation, rat: LC50 = 130 mg/m3/4H; Inhalation, rat: LC50 = 67 ppm(NO2)/4H.
CAS# 7732-18-5: Oral, rat: LD50 = >90 mL/kg.
Carcinogenicity:
Manganese - Not listed by ACGIH, IARC, or NTP.
Nitric acid - Not listed by ACGIH, IARC, or NTP.
Water - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
CAS# 7439-96-5: OO9275000 CAS# 7697-37-2: QU5775000 QU5900000 CAS# 7732-18-5: ZC0110000 LD50/LC50:
CAS# 7439-96-5: Draize test, rabbit, eye: 500 mg/24H Mild; Draize test, rabbit, skin: 500 mg/24H Mild; Oral, rat: LD50 = 9 gm/kg.
CAS# 7697-37-2: Inhalation, rat: LC50 = 260 mg/m3/30M; Inhalation, rat: LC50 = 130 mg/m3/4H; Inhalation, rat: LC50 = 67 ppm(NO2)/4H.
CAS# 7732-18-5: Oral, rat: LD50 = >90 mL/kg.
Carcinogenicity:
Manganese - Not listed by ACGIH, IARC, or NTP.
Nitric acid - Not listed by ACGIH, IARC, or NTP.
Water - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
Section 12 - ECOLOGICAL INFORMATION
Ecotoxicity:
Nitric Acid: Mosquito fish: TLm=72 ppm/96H (fresh water) Cockle: LC50=330-1000 ppm/48H (salt water)
Nitric Acid: Mosquito fish: TLm=72 ppm/96H (fresh water) Cockle: LC50=330-1000 ppm/48H (salt water)
Section 13 - DISPOSAL CONSIDERATIONS
Products which are considered hazardous for supply are classified as Special Waste and the disposal of such chemicals is covered by regulations which may vary according to location. Contact a specialist disposal company or the local waste regulator for advice. Empty containers must be decontaminated before returning for recycling.
Section 14 - TRANSPORT INFORMATION
IATA
Shipping Name: Nitric Acid Solution
Hazard Class: 8
UN Number: 2031
Packing Group: II
IMO
Shipping Name: Nitric Acid Solution
Hazard Class: 8
UN Number: 2031
Packing Group: II
RID/ADR
Shipping Name: Nitric Acid Solution
Hazard Class: 8
UN Number: 2031
Packing group: II
USA RQ: CAS# 7697-37-2: 1000 lb final RQ; 454 kg final RQ
Section 15 - REGULATORY INFORMATION
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: C
Risk Phrases:
R 34 Causes burns.
Safety Phrases:
S 23 Do not inhale gas/fumes/vapour/spray.
S 26 In case of contact with eyes, rinse immediately
with plenty of water and seek medical advice.
S 36 Wear suitable protective clothing.
S 45 In case of accident or if you feel unwell, seek
medical advice immediately (show the label where
possible).
WGK (Water Danger/Protection)
CAS# 7439-96-5: No information available.
CAS# 7697-37-2: 1
CAS# 7732-18-5: No information available.
Canada
CAS# 7439-96-5 is listed on Canadas DSL List.
CAS# 7697-37-2 is listed on Canadas DSL List.
CAS# 7732-18-5 is listed on Canadas DSL List.
CAS# 7439-96-5 is listed on Canadas Ingredient Disclosure List.
CAS# 7697-37-2 is listed on Canadas Ingredient Disclosure List.
CAS# 7732-18-5 is not listed on Canadas Ingredient Disclosure List.
US FEDERAL
TSCA
CAS# 7439-96-5 is listed on the TSCA inventory.
CAS# 7697-37-2 is listed on the TSCA inventory.
CAS# 7732-18-5 is listed on the TSCA inventory.
