Name:
Phthalic Anhydride
Synonym:
Non
CAS:
85-44-9
Section 1 - Chemical Product
MSDS Name:Phthalic Anhydride
Synonym:Non
Synonym:Non
Section 2 - COMPOSITION, INFORMATION ON INGREDIENTS
| CAS# | Chemical Name | emsds | EINECS# |
| 85-44-9 | Phthalic anhydride | 100.0 | 201-607-5 |
| Hazard Symbols: XI Risk Phrases: 36/37/38 |
Section 3 - HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
Irritating to eyes, respiratory system and skin.Corrosive.
Potential Health Effects
Eye:
Contact with eyes may cause severe irritation, and possible eye burns.
Skin:
May cause skin sensitization, an allergic reaction, which becomes evident upon re-exposure to this material. May cause severe irritation and possible burns.
Ingestion:
Causes gastrointestinal tract burns.
Inhalation:
May cause severe irritation of the respiratory tract with sore throat, coughing, shortness of breath and delayed lung edema. Causes chemical burns to the respiratory tract.
Chronic:
Chronic inhalation and ingestion may cause effects similar to those of acute inhalation and ingestion.
Irritating to eyes, respiratory system and skin.Corrosive.
Potential Health Effects
Eye:
Contact with eyes may cause severe irritation, and possible eye burns.
Skin:
May cause skin sensitization, an allergic reaction, which becomes evident upon re-exposure to this material. May cause severe irritation and possible burns.
Ingestion:
Causes gastrointestinal tract burns.
Inhalation:
May cause severe irritation of the respiratory tract with sore throat, coughing, shortness of breath and delayed lung edema. Causes chemical burns to the respiratory tract.
Chronic:
Chronic inhalation and ingestion may cause effects similar to those of acute inhalation and ingestion.
Section 4 - FIRST AID MEASURES
Eyes: Immediately flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid immediately.
Skin:
Get medical aid immediately. Immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes. Destroy contaminated shoes.
Ingestion:
Get medical aid immediately. Do NOT induce vomiting. If conscious and alert, rinse mouth and drink 2-4 cupfuls of milk or water.
Inhalation:
Get medical aid immediately. Remove from exposure and move to fresh air immediately. If not breathing, give artificial respiration. If breathing is difficult, give oxygen.
Notes to Physician:
Skin:
Get medical aid immediately. Immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes. Destroy contaminated shoes.
Ingestion:
Get medical aid immediately. Do NOT induce vomiting. If conscious and alert, rinse mouth and drink 2-4 cupfuls of milk or water.
Inhalation:
Get medical aid immediately. Remove from exposure and move to fresh air immediately. If not breathing, give artificial respiration. If breathing is difficult, give oxygen.
Notes to Physician:
Section 5 - FIRE FIGHTING MEASURES
General Information:
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear.
Extinguishing Media:
In case of fire, use water, dry chemical, chemical foam, or alcohol-resistant foam.
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear.
Extinguishing Media:
In case of fire, use water, dry chemical, chemical foam, or alcohol-resistant foam.
Section 6 - ACCIDENTAL RELEASE MEASURES
General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks:
Sweep up, then place into a suitable container for disposal.
Spills/Leaks:
Sweep up, then place into a suitable container for disposal.
Section 7 - HANDLING and STORAGE
Handling:
Wash thoroughly after handling. Use with adequate ventilation. Do not get in eyes, on skin, or on clothing. Do not ingest or inhale.
Storage:
Keep container closed when not in use. Store in a cool, dry, well-ventilated area away from incompatible substances.
Wash thoroughly after handling. Use with adequate ventilation. Do not get in eyes, on skin, or on clothing. Do not ingest or inhale.
Storage:
Keep container closed when not in use. Store in a cool, dry, well-ventilated area away from incompatible substances.
Section 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION
Engineering Controls:
Use adequate general or local exhaust ventilation to keep airborne concentrations below the permissible exposure limits.
Exposure Limits CAS# 85-44-9: United Kingdom, WEL - TWA: 4 mg/m3 TWA United Kingdom, WEL - STEL: 12 mg/m3 STEL United States OSHA: 2 ppm TWA; 12 mg/m3 TWA Belgium - TWA: 1 ppm VLE; 6.2 mg/m3 VLE France - VLE: 6 mg/m3 VLE Germany: 1 mg/m3 TWA (inhalable fraction) Japan: 0.33 ppm Ceiling; 0.2 mg/m3 Ceiling Malaysia: 1 ppm TWA; 6.1 mg/m3 TWA Netherlands: 2 mg/m3 STEL Netherlands: 1 mg/m3 MAC Russia: 1 mg/m3 TWA Spain: 1 ppm VLA-ED; 6 mg/m3 VLA-ED Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHAs eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear appropriate protective gloves and clothing to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to minimize contact with skin.
Respirators:
Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced.
Use adequate general or local exhaust ventilation to keep airborne concentrations below the permissible exposure limits.
Exposure Limits CAS# 85-44-9: United Kingdom, WEL - TWA: 4 mg/m3 TWA United Kingdom, WEL - STEL: 12 mg/m3 STEL United States OSHA: 2 ppm TWA; 12 mg/m3 TWA Belgium - TWA: 1 ppm VLE; 6.2 mg/m3 VLE France - VLE: 6 mg/m3 VLE Germany: 1 mg/m3 TWA (inhalable fraction) Japan: 0.33 ppm Ceiling; 0.2 mg/m3 Ceiling Malaysia: 1 ppm TWA; 6.1 mg/m3 TWA Netherlands: 2 mg/m3 STEL Netherlands: 1 mg/m3 MAC Russia: 1 mg/m3 TWA Spain: 1 ppm VLA-ED; 6 mg/m3 VLA-ED Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHAs eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear appropriate protective gloves and clothing to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to minimize contact with skin.
Respirators:
Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced.
Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Solid
Color: white
Odor: None reported.
pH: Not available.
Vapor Pressure: Not available.
Viscosity: Not available.
Boiling Point: 284 deg C
Freezing/Melting Point: 131 deg C
Autoignition Temperature: Not applicable.
Flash Point: 151 deg C ( 303.80 deg F)
Explosion Limits, lower: 1.2
Explosion Limits, upper: 9.2
Decomposition Temperature:
Solubility in water: Very crystalline flakes
Specific Gravity/Density: Not available.
Molecular Formula: C6H4(CO)2O
Molecular Weight: 148.0262
Section 10 - STABILITY AND REACTIVITY
Chemical Stability:
Stable under normal temperatures and pressures.
Conditions to Avoid:
Incompatible materials.
Incompatibilities with Other Materials:
Strong acids - strong bases - strong oxidizing agents - strong reducing agents - moisture.
Hazardous Decomposition Products:
Carbon monoxide, carbon dioxide.
Hazardous Polymerization: Has not been reported.
Stable under normal temperatures and pressures.
Conditions to Avoid:
Incompatible materials.
Incompatibilities with Other Materials:
Strong acids - strong bases - strong oxidizing agents - strong reducing agents - moisture.
Hazardous Decomposition Products:
Carbon monoxide, carbon dioxide.
Hazardous Polymerization: Has not been reported.
Section 11 - TOXICOLOGICAL INFORMATION
RTECS#:
CAS# 85-44-9: TI3150000 LD50/LC50:
CAS# 85-44-9: Draize test, rabbit, eye: 50 mg/24H Moderate; Draize test, rabbit, skin: 500 mg/24H Mild; Inhalation, rat: LC50 = >210 mg/m3/1H; Oral, mouse: LD50 = 1500 mg/kg; Oral, rat: LD50 = 1530 mg/kg; Skin, rabbit: LD50 = >10 gm/kg.
Carcinogenicity:
Phthalic anhydride - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
CAS# 85-44-9: TI3150000 LD50/LC50:
CAS# 85-44-9: Draize test, rabbit, eye: 50 mg/24H Moderate; Draize test, rabbit, skin: 500 mg/24H Mild; Inhalation, rat: LC50 = >210 mg/m3/1H; Oral, mouse: LD50 = 1500 mg/kg; Oral, rat: LD50 = 1530 mg/kg; Skin, rabbit: LD50 = >10 gm/kg.
Carcinogenicity:
Phthalic anhydride - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
Section 12 - ECOLOGICAL INFORMATION
Section 13 - DISPOSAL CONSIDERATIONS
Products which are considered hazardous for supply are classified as Special Waste and the disposal of such chemicals is covered by regulations which may vary according to location. Contact a specialist disposal company or the local waste regulator for advice. Empty containers must be decontaminated before returning for recycling.
Section 14 - TRANSPORT INFORMATION
IATA
Shipping Name: PHTHALIC ANHYDRIDE
Hazard Class: 8
UN Number: 2214
Packing Group: III
IMO
Shipping Name: PHTHALIC ANHYDRIDE
Hazard Class: 8
UN Number: 2214
Packing Group: III
RID/ADR
Shipping Name: PHTHALIC ANHYDRIDE
Hazard Class: 8
UN Number: 2214
Packing group: III
USA RQ: CAS# 85-44-9: 5000 lb final RQ; 2270 kg final RQ
Section 15 - REGULATORY INFORMATION
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: XI
Risk Phrases:
R 36/37/38 Irritating to eyes, respiratory system
and skin.
Safety Phrases:
WGK (Water Danger/Protection)
CAS# 85-44-9: 0
Canada
CAS# 85-44-9 is listed on Canadas DSL List.
CAS# 85-44-9 is listed on Canadas Ingredient Disclosure List.
US FEDERAL
TSCA
CAS# 85-44-9 is listed on the TSCA inventory.
