Name:
Sulfuric acid volumetric solutions 0.1M
Synonym:
0.1M Solutio
CAS:
7664-93-9
Section 1 - Chemical Product
MSDS Name:Sulfuric acid volumetric solutions 0.1M
Synonym:0.1M Solutio
Synonym:0.1M Solutio
Section 2 - COMPOSITION, INFORMATION ON INGREDIENTS
| CAS# | Chemical Name | emsds | EINECS# |
| 7664-93-9 | Sulfuric acid | 0.94 | 231-639-5 |
| Hazard Symbols: C Risk Phrases: 34 |
Section 3 - HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
Causes burns.Corrosive.
Potential Health Effects
Eye:
Causes severe eye burns. May cause irreversible eye injury.
Skin:
Causes skin burns.
Ingestion:
Causes gastrointestinal tract burns. May cause corrosion and permanent tissue destruction of the esophagus and digestive tract.
Inhalation:
Irritation may lead to chemical pneumonitis and pulmonary edema. May cause severe irritation of the respiratory tract with sore throat, coughing, shortness of breath and delayed lung edema. May cause severe respiratory tract irritation and possible burns. Exposure may lead to bronchitis, pharyngitis, and dental erosion.
Chronic:
Repeated exposure may cause erosion of teeth.
Causes burns.Corrosive.
Potential Health Effects
Eye:
Causes severe eye burns. May cause irreversible eye injury.
Skin:
Causes skin burns.
Ingestion:
Causes gastrointestinal tract burns. May cause corrosion and permanent tissue destruction of the esophagus and digestive tract.
Inhalation:
Irritation may lead to chemical pneumonitis and pulmonary edema. May cause severe irritation of the respiratory tract with sore throat, coughing, shortness of breath and delayed lung edema. May cause severe respiratory tract irritation and possible burns. Exposure may lead to bronchitis, pharyngitis, and dental erosion.
Chronic:
Repeated exposure may cause erosion of teeth.
Section 4 - FIRST AID MEASURES
Eyes: Flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid immediately. Do NOT allow victim to rub eyes or keep eyes closed.
Skin:
Get medical aid immediately. Flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Discard contaminated clothing in a manner which limits further exposure. SPEEDY ACTION IS CRITICAL! Ingestion:
Do not induce vomiting. If victim is conscious and alert, give 2-4 cupfuls of milk or water. Never give anything by mouth to an unconscious person. Get medical aid immediately.
Inhalation:
Get medical aid immediately. Remove from exposure and move to fresh air immediately. If breathing is difficult, give oxygen. Do NOT use mouth-to-mouth resuscitation. If breathing has ceased apply artificial respiration using oxygen and a suitable mechanical device such as a bag and a mask.
Notes to Physician:
Skin:
Get medical aid immediately. Flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Discard contaminated clothing in a manner which limits further exposure. SPEEDY ACTION IS CRITICAL! Ingestion:
Do not induce vomiting. If victim is conscious and alert, give 2-4 cupfuls of milk or water. Never give anything by mouth to an unconscious person. Get medical aid immediately.
Inhalation:
Get medical aid immediately. Remove from exposure and move to fresh air immediately. If breathing is difficult, give oxygen. Do NOT use mouth-to-mouth resuscitation. If breathing has ceased apply artificial respiration using oxygen and a suitable mechanical device such as a bag and a mask.
Notes to Physician:
Section 5 - FIRE FIGHTING MEASURES
General Information:
Wear appropriate protective clothing to prevent contact with skin and eyes. Wear a self-contained breathing apparatus (SCBA) to prevent contact with thermal decomposition products. Reaction with water may generate much heat which will increase the concentration of fumes in the air. Contact with metals may evolve flammable hydrogen gas. Substance may react with water, and may release corrosive and/or toxic gases. Containers may explode when heated or if contaminated with water.
Extinguishing Media:
Do NOT get water inside containers. Do NOT use straight streams of water. For large fires, use dry chemical, carbon dioxide, alcohol-resistant foam, or water spray. Cool containers with flooding quantities of water until well after fire is out. For small fires, use dry chemical, dry sand, alcohol-resistant foam.
Wear appropriate protective clothing to prevent contact with skin and eyes. Wear a self-contained breathing apparatus (SCBA) to prevent contact with thermal decomposition products. Reaction with water may generate much heat which will increase the concentration of fumes in the air. Contact with metals may evolve flammable hydrogen gas. Substance may react with water, and may release corrosive and/or toxic gases. Containers may explode when heated or if contaminated with water.
Extinguishing Media:
Do NOT get water inside containers. Do NOT use straight streams of water. For large fires, use dry chemical, carbon dioxide, alcohol-resistant foam, or water spray. Cool containers with flooding quantities of water until well after fire is out. For small fires, use dry chemical, dry sand, alcohol-resistant foam.
Section 6 - ACCIDENTAL RELEASE MEASURES
General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks:
Cover with sand, dry lime or soda ash and place in a closed container for disposal. Remove all sources of ignition. Do not get water inside containers. A vapor suppressing foam may be used to reduce vapors.
Spills/Leaks:
Cover with sand, dry lime or soda ash and place in a closed container for disposal. Remove all sources of ignition. Do not get water inside containers. A vapor suppressing foam may be used to reduce vapors.
Section 7 - HANDLING and STORAGE
Handling:
Wash thoroughly after handling. Remove contaminated clothing and wash before reuse. Use only in a well-ventilated area. Do not get in eyes, on skin, or on clothing. Keep container tightly closed. Do not ingest or inhale.
Storage:
Do not store near combustible materials. Keep container closed when not in use. Store in a cool, dry, well-ventilated area away from incompatible substances. Do not store near alkaline substances.
Wash thoroughly after handling. Remove contaminated clothing and wash before reuse. Use only in a well-ventilated area. Do not get in eyes, on skin, or on clothing. Keep container tightly closed. Do not ingest or inhale.
Storage:
Do not store near combustible materials. Keep container closed when not in use. Store in a cool, dry, well-ventilated area away from incompatible substances. Do not store near alkaline substances.
Section 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION
Engineering Controls:
Use process enclosure, local exhaust ventilation, or other engineering controls to control airborne levels below recommended exposure limits.
Exposure Limits CAS# 7664-93-9: United States OSHA: 1 mg/m3 TWA Belgium - TWA: 1 mg/m3 VLE Belgium - STEL: 3 mg/m3 VLE France - VME: 1 mg/m3 VME France - VLE: 3 mg/m3 VLE Germany: 0.5 mg/m3 TWA (inhalable fraction, battery manufacture, metal working in a close Japan: 1 mg/m3 Ceiling Malaysia: 1 mg/m3 TWA Netherlands: 1 mg/m3 MAC Russia: 1 mg/m3 TWA Spain: 1 mg/m3 VLA-ED Spain: 3 mg/m3 VLA-EC CAS# 7732-18-5: Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHAs eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced.
Use process enclosure, local exhaust ventilation, or other engineering controls to control airborne levels below recommended exposure limits.
Exposure Limits CAS# 7664-93-9: United States OSHA: 1 mg/m3 TWA Belgium - TWA: 1 mg/m3 VLE Belgium - STEL: 3 mg/m3 VLE France - VME: 1 mg/m3 VME France - VLE: 3 mg/m3 VLE Germany: 0.5 mg/m3 TWA (inhalable fraction, battery manufacture, metal working in a close Japan: 1 mg/m3 Ceiling Malaysia: 1 mg/m3 TWA Netherlands: 1 mg/m3 MAC Russia: 1 mg/m3 TWA Spain: 1 mg/m3 VLA-ED Spain: 3 mg/m3 VLA-EC CAS# 7732-18-5: Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHAs eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced.
Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Liquid
Color: colorless
Odor: Not available.
pH: <1.0
Vapor Pressure: Not available.
Viscosity: Not available.
Boiling Point: Not available.
Freezing/Melting Point: Not available.
Autoignition Temperature: Not applicable.
Flash Point: Not applicable.
Explosion Limits, lower: Not available.
Explosion Limits, upper: Not available.
Decomposition Temperature: Not available.
Solubility in water: Not available.
Specific Gravity/Density: >1.0
Molecular Formula: Mixture
Molecular Weight: Not available
Section 10 - STABILITY AND REACTIVITY
Chemical Stability:
Stable under normal temperatures and pressures.
Conditions to Avoid:
Incompatible materials, metals, excess heat, combustible materials, organic materials, oxidizers, amines, bases.
Incompatibilities with Other Materials:
Acetic Anhydride, Acetone Cyanhydrin, Acetone + Nitric Acid, Acetone + Potassium Dichromate, Acetonitrile, Acrolein, Acrylonitrile, Alcohols + Hydrogen Peroxide, Allyl Alcohol, Allyl Chloride, 2-Aminoethanol, Ammonium Hydroxide, Ammonium Triperchromate, Aniline, Bromates + Metals, Bromine Pentafluoride, n-Butyraldehyde, Carbides, Cesium Acetylene Carbide, Chlorates, Chlorine Trifluoride, Chlorosulfonic Acid, Cuprous Nitride, Diisobutylene, Epichlorohydrin, Ethylene Cyanohydrin, Ethylene Diamine, Ethylene Glycol, Ethylenimine, Fulminates, Other Acids, Iodine Heptafluoride, Metals, Isoprene, Lithium Silicide, Mercuric Nitride, Mesityl Oxide, P-Nitrotoluene, Pentasilver Trihydroxydiaminophosphate, Perchlorates, Permanganates + Benzene, Phosphorus, Phosphorus Isocyanate, Picrates, Potassium t-Butoxide, Potassium Chlorate, Permanganates, beta-Propiolactone, Propylene Oxide, Pyridine, Rubidium Acetylene Carbide and Sodium.
Hazardous Decomposition Products:
Oxides of sulfur.
Hazardous Polymerization: Has not been reported.
Stable under normal temperatures and pressures.
Conditions to Avoid:
Incompatible materials, metals, excess heat, combustible materials, organic materials, oxidizers, amines, bases.
Incompatibilities with Other Materials:
Acetic Anhydride, Acetone Cyanhydrin, Acetone + Nitric Acid, Acetone + Potassium Dichromate, Acetonitrile, Acrolein, Acrylonitrile, Alcohols + Hydrogen Peroxide, Allyl Alcohol, Allyl Chloride, 2-Aminoethanol, Ammonium Hydroxide, Ammonium Triperchromate, Aniline, Bromates + Metals, Bromine Pentafluoride, n-Butyraldehyde, Carbides, Cesium Acetylene Carbide, Chlorates, Chlorine Trifluoride, Chlorosulfonic Acid, Cuprous Nitride, Diisobutylene, Epichlorohydrin, Ethylene Cyanohydrin, Ethylene Diamine, Ethylene Glycol, Ethylenimine, Fulminates, Other Acids, Iodine Heptafluoride, Metals, Isoprene, Lithium Silicide, Mercuric Nitride, Mesityl Oxide, P-Nitrotoluene, Pentasilver Trihydroxydiaminophosphate, Perchlorates, Permanganates + Benzene, Phosphorus, Phosphorus Isocyanate, Picrates, Potassium t-Butoxide, Potassium Chlorate, Permanganates, beta-Propiolactone, Propylene Oxide, Pyridine, Rubidium Acetylene Carbide and Sodium.
Hazardous Decomposition Products:
Oxides of sulfur.
Hazardous Polymerization: Has not been reported.
Section 11 - TOXICOLOGICAL INFORMATION
RTECS#:
CAS# 7664-93-9: WS5600000 CAS# 7732-18-5: ZC0110000 LD50/LC50:
CAS# 7664-93-9: Draize test, rabbit, eye: 250 ug Severe; Inhalation, mouse: LC50 = 320 mg/m3/2H; Inhalation, mouse: LC50 = 320 mg/m3; Inhalation, rat: LC50 = 510 mg/m3/2H; Inhalation, rat: LC50 = 510 mg/m3; Oral, rat: LD50 = 2140 mg/kg.
CAS# 7732-18-5: Oral, rat: LD50 = >90 mL/kg.
Carcinogenicity:
Sulfuric acid - ACGIH: A2 - Suspected Human Carcinogen (contained in strong inorg California: carcinogen, initial date 3/14/03 (listed as Strong inorgan NTP: Known carcinogen (listed as Strong inorganic acid mists co IARC: Group 1 carcinogen Water - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
CAS# 7664-93-9: WS5600000 CAS# 7732-18-5: ZC0110000 LD50/LC50:
CAS# 7664-93-9: Draize test, rabbit, eye: 250 ug Severe; Inhalation, mouse: LC50 = 320 mg/m3/2H; Inhalation, mouse: LC50 = 320 mg/m3; Inhalation, rat: LC50 = 510 mg/m3/2H; Inhalation, rat: LC50 = 510 mg/m3; Oral, rat: LD50 = 2140 mg/kg.
CAS# 7732-18-5: Oral, rat: LD50 = >90 mL/kg.
Carcinogenicity:
Sulfuric acid - ACGIH: A2 - Suspected Human Carcinogen (contained in strong inorg California: carcinogen, initial date 3/14/03 (listed as Strong inorgan NTP: Known carcinogen (listed as Strong inorganic acid mists co IARC: Group 1 carcinogen Water - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
Section 12 - ECOLOGICAL INFORMATION
Ecotoxicity:
Sulfuric acid is harmful to aquatic life in very low concentrations.
It may be dangerous if it enters water intakes. The aquatic toxicity for bluegill in fresh water was 24.5 ppm/24 hr, which was lethal.
Sulfuric acid is harmful to aquatic life in very low concentrations.
It may be dangerous if it enters water intakes. The aquatic toxicity for bluegill in fresh water was 24.5 ppm/24 hr, which was lethal.
Section 13 - DISPOSAL CONSIDERATIONS
Products which are considered hazardous for supply are classified as Special Waste and the disposal of such chemicals is covered by regulations which may vary according to location. Contact a specialist disposal company or the local waste regulator for advice. Empty containers must be decontaminated before returning for recycling.
Section 14 - TRANSPORT INFORMATION
IATA
Not regulated as a hazardous material.
IMO
Not regulated as a hazardous material.
RID/ADR
Not regulated as a hazardous material.
USA RQ: CAS# 7664-93-9: 1000 lb final RQ; 454 kg final RQ
Section 15 - REGULATORY INFORMATION
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: C
Risk Phrases:
R 34 Causes burns.
Safety Phrases:
S 23 Do not inhale gas/fumes/vapour/spray.
S 24/25 Avoid contact with skin and eyes.
S 26 In case of contact with eyes, rinse immediately
with plenty of water and seek medical advice.
S 28B After contact with skin, wash immediately with
plenty of water and soap.
S 45 In case of accident or if you feel unwell, seek
medical advice immediately (show the label where
possible).
WGK (Water Danger/Protection)
CAS# 7664-93-9: 2
CAS# 7732-18-5: No information available.
Canada
CAS# 7664-93-9 is listed on Canadas DSL List.
CAS# 7732-18-5 is listed on Canadas DSL List.
CAS# 7664-93-9 is listed on Canadas Ingredient Disclosure List.
CAS# 7732-18-5 is not listed on Canadas Ingredient Disclosure List.
US FEDERAL
TSCA
CAS# 7664-93-9 is listed on the TSCA inventory.
CAS# 7732-18-5 is listed on the TSCA inventory.
